2002 DODGE RAM 2500 Fuel System Otherdeliveryfuel Pump Problems

TL*THE CONTACT OWNS A 2002 DODGE RAM 2500. THE CONTACT EXPERIENCED ISSUES WITH THE 6-SPEED MANUAL TRANSMISSION IN HIS VEHICLE. THE CLUTCH WOULD FAIL WHILE DRIVING AT VARIOUS SPEEDS. IN ADDITION, THE GEARS WOULD SLIP AS IF THE CLUTCH WERE DEPRESSED AND THE CONTACT SMELLED A BURNING ODOR WHILE DRIVING IN REVERSE. HE TOOK THE VEHICLE TO MULTIPLE DEALERS MORE THAN TEN TIMES. ONE OF THE DEALERS INSTALLED A NEW CLUTCH, BUT IT FAILED 10,000 MILES LATER. AT APPROXIMATELY 34,000 MILES, THE DEALER REPAIRED THE CLUTCH AGAIN; HOWEVER, THE ISSUE RECURRED. THE MANUFACTURER OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 37,000 AND FAILURE MILEAGE WAS APPROXIMATELY 500. UPDATED 1/5/09 *CN THE CONSUMER ALSO STATED WHEN BACKING UP HIS TRAILER THERE WAS A BURNING SMELL COMING FROM THE CLUTCH AREA. A TRANSMISSION SHOP EXAMINED THE CLUTCH AND PRESSURE PLATED AND DISCOVERED THE CLUTCH WAS WORN AND THE PRESSURE PLATE HAD...

TL*THE CONTACT OWNS A 2002 DODGE RAM 2500. THE CONTACT STATED THAT THE CLUTCH LOCKED UP AND THE VEHICLE WAS INOPERABLE. WHILE DRIVING 55 MPH, IT SEEMS AS IF THE CLUTCH RELEASES AND THE RPMS INCREASE BEFORE THE VEHICLE BEGINS TO DRIVE NORMALLY. THE CONTACT TOOK THE VEHICLE TO A DEALER APPROXIMATELY TWELVE TIMES, BUT THEY CAN NEVER DUPLICATE THE FAILURE. THE CLUTCH HAS BEEN REPLACED TWICE. THE FAILURE OCCURS INTERMITTENTLY. THE CURRENT MILEAGE WAS 35,000 AND FAILURE MILEAGE WAS 500. UPDATED 01/24/08 *BF THE DEALER STATED WIRING PLUG FUSE BLOWN, ALARM WILL GO OFF WITH KEY IN IGNITION OR NOT, PDC COVER BROKEN, DIFFICULT TO START IN COLD WEATHER, NOTICED A BURNING SMELL, AND FUEL INJECTION. UPDATED 01/24/08 *TR

I RECENTLY EXPERIENCED THIS WHILE I DRIVING WITH TRAILER IN TOW AND HAD LOSS OF POWER. BEING FOLLOWED BY TRAFFIC I WAS UNABLE TO ACCELERATE UP THE HILL. I HAVE ALSO EXPERIENCED PROBLEMS WHEN TURNING INTO TRAFFIC THE LOSS OF POWER AND UNABLE TO ACCELERATE HAS CAUSED OTHER DRIVERS TO PERFORM DRASTIC BRAKING AND MANEUVERING TO AVOID COLLISIONS. WHAT HAPPENS IS THE ENGINE DOES NOT RESPOND TO THE FUEL PEDAL INPUT. I HAVE CHECKED THE CODES ON THE DODGE RAM 2500 EQUIPPED WITH THE 5.9L CUMMINS TURBO DIESEL AND HAVE FOUND A P0216 CODE INDICATING THE BOSCH VP44 INJECTION PUMP IS NOT COMMUNICATING WITH THE ECM. THERE APPEARS TO BE A DEFECT IN THE VP44 COMPUTER TALKING WITH THE ECM. THIS WAS NOT THE FIRST TIME THE "DEAD PEDAL" ISSUE OCCURRED. THIS FIRST STARTED AROUND 36000 MILES AFTER A LONG HIGHWAY TRIP COMING TO A STOP AFTER WHICH THE ENGINE...