2004 DODGE CARAVAN Fuel System Gasoline Problems

2004 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO FUEL TANK EXTENDED WARRANTY COVERAGE THAT APPLIES TO VEHICLE STALLING AFTER REFUELING. *SMD THE CONSUMER STATED THE VEHICLE BEGAN STALLING SHORTLY AFTER IT WAS PURCHASED AND HAS SINCE CONTINUED. THE STALLING OCCURRED AT HIGHWAY SPEEDS AND WHILE MAKING LEFT TURNS. ALSO, THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALER REPLACED THE EGR SENSOR.*JB

2004 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO GAS GAUGE PROBLEMS. *SMD THE CONSUMER ALSO STATED THE VEHICLE IS LEAKING GAS.*JB

I WAS TRAVELING ON THE FREEWAY AT SPEED OR SLIGHTLY ABOVE WHEN MY GAS LIGHT WENT ON AND THE VAN STARTED TO SPUTTER. THEN THE ENGINE LIGHT WENT ON AND MY SPEED DECREASED TO APPX 40 MPH. I IMMEDIATELY GOT TO THE SIDE OF THE ROAD DURING RUSH HOUR AND CARS SPEEDING BY ME. IT WAS EXTREMELY DANGEROUS AND SCARY. A POLICE OFFICER STOPPED TO ASSIST ME AND TRY TO GET ME TOWED. I MADE IT TO THE NEXT GAS STATION. I ADDED GAS AND OIL. HOWEVER, DUE TO THE FACT THAT IT WAS SHAKING AND NOT ABLE TO MAKE IT ABOVE 40 MPH, I DECIDED TO HAVE IT TOWED HOME UNTIL A DECISION COULD BE MADE ABOUT WHAT TO DO. THE NEXT MORNING WE TOWED TO OUR MECHANIC AND IT WAS DISCOVERED THAT THE ENGINE DROPPED. THE BOLTS THAT HELD IT IN FAILED. I AM LUCKY. NOW WE HAVE...

THIS COMPLAINT IS ABOUT ANOTHER 2004 DODGE CARAVAN THAT STALLS AFTER FILLING UP THE TANK. THE PROBLEM IS THAT THE STALLING OCCURS WITHOUT WARNING-I.E. IN THE MIDDLE OF CROSSING AN INTERSECTION OR,SAY, PULLING OUT OF THE GAS STATION INTO TRAFFIC! SPOKE WITH CHRYSLER THIS MORNING ABOUT IT AND THEY SEEM OBLIVIOUS TO THE PROBLEM. KIND OF HARD TO BELIEVE SINCE ALL YOU HAVE TO DO IS GOOGLE "CARAVAN STALLS AFTER FILLING UP" AND THERE ARE THOUSANDS OF COMPLAINTS ONLINE. MECHANICS ARE AWARE OF THE PROBLEM BUT THE GENERAL PUBLIC ONLY SEEMS TO BE AWARE AFTER THE OCCURRENCE! PLEASE TAKE SOME TIME TO CHECK INTO THIS BEFORE SOME LITTLE KID GETS HURT. *TR

THIS COMPLAINT IS FOR A 2004 DODGE CARAVAN THE PROBLEM OCCURS WHEN THE GAS TANK IS FILLED. THE VEHICLE STALLS AND RUNS ROUGH FOR SEVERAL MILES AND SOMETIMES MANY MORE. I BELIEVE THE DEFECT IS THE LIQUID/VAPOR VALVE BUILT INTO THE TOP OF THE FUEL TANK. IT FAILS AND ALLOWS FUEL INTO THE EVAC CANISTER AND VAPOR LINES WHICH COULD EXPLODE OR CAUSE A FIRE AS THEY ARE NOT DESIGNED TO HOLD GASOLINE. CHRYSLER SEEMS TO CARE LESS. I'M SURE WHEN PEOPLE START TO BURN TO DEATH SOMETHING WILL BE DONE. THANK YOU *TR

CONSUMER SMELLED GAS, THE PASSENGER BECAME ILL. CONSUMER PARKED THE VEHICLE AND A PASSERBY TOLD THE CONSUMER NOT TO START THE VEHICLE BECAUSE, GAS WAS ALL OVER THE STREET. THE VEHICLE WAS TOWED.*AK