2000 DODGE CARAVAN Steering Problems

TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE POWER STEERING SEIZED FOR THE THIRD TIME. AFTER THE PREVIOUS FAILURES, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE SERPENTINE BELT SLIPPED OFF AND NEEDED TO BE REPLACED. AFTER THE RECENT FAILURE, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

WHEN I TRIED TO PULL MY DODGE CARAVAN (2000) OUT OF THE PARKING LOT AFTER A HEAVY RAINING DAY, I FOUND THE POWER STEERING DIDN'T WORK. I COULD GO FORWARD OR BACKWARD, BUT COULD NOT TURN, OR COULD TURN ONLY VERY SLOWLY (I COULD HEAR THE WHEEL KIND OF MAKING CLICKING SOUND WHEN I TRIED TO TURN). AFTER DRIVING VERY SLOWLY ON THE PARKING LOT AND TRIED TO TURN SLOWLY SEVERAL TIME, THE STEERING FINALLY GOT BACK. I GOOGLED ONLINE AND FOUND MANY PEOPLE HAVE THE SAME PROBLEM, MOSTLY WITH A DODGE, BUT ALSO SOME OTHER CARS. HTTP://WWW.TOPIX.COM/FORUM/AUTOS/DODGE-GRAND-CARAVAN/TC37VJLP6MD4POHVJ SINCE I DON'T DRIVE MUCH AND MOSTLY PARK MY VEHICLE IN THE GARAGE, I DON'T HAVE MUCH PROBLEM. IT HAS HAPPENED A COUPLE MORE TIMES AFTER THE FIRST INCIDENT, BUT IT USUALLY RETURNS NORMAL AFTER I MAKE SEVERAL SMALL TURNS IN THE PARKING LOT. BUT THIS MORNING, IT HAPPENED AGAIN, AFTER I...

DRIVING IN A RAINSTORM THE DRIVE BELT CAME OFF WHILE DRIVING ONTO THE ENTRANCE RAMP OF C270. THE POWER STEERING, WATER PUMP, GENERATOR FAILED. THE CAR WAS NOT ABLE TO DRIVE. *TR

WHILE DRIVING DOWN THE HIGHWAY IT STARTED TO RAIN AND THE POWER STEERING FAILED FOR UNKNOWN REASONS. THE HEATER FAN STOPPED WHICH MADE IT IMPOSSIBLE TO CLEAR THE WINDOWS, THE VEHICLE QUICKLY OVERHEATED, THE LOW BATTERY LIGHT CAME ON. WAS ABLE TO GET TO THE SIDE OF THE ROAD WITH MUCH DIFFICULTY AND DISCOVERED THE POWER STEERING BELT HAD DROPPED OFF. THIS HAS HAPPENED REPEATEDLY EVERY TIME IT RAINS EVEN A LITTLE BIT AND IS VERY MUCH A SAFETY HAZARD. IT HAS MADE THE VEHICLE VERY UNRELIABLE. MERELY RECONNECTING THE BELT IS NOT A SOLUTION TO THIS ISSUE. I WAS WONDERING IF THERE HAS BEEN A RECALL FOR THE PROBLEM. *TR

TODAY I WAS ON AN URBAN FREEWAY IN HEAVY DOWNPOUR. THE DOWNPOUR WAS SO HEAVY RAIN COULD BE SEEN RUNNING OFF THE ROAD. TRAFFIC WAS WIDE SPREAD, BUT MOVING AT 45-50 MPH, DUE TO THE RAIN. MY WIPERS, AT THE HIGHEST SETTING, SLOW DOWN. CAR DINGS. BATTERY LIGHT COMES ON. I TURN OFF THE DEFROSTER (AC AND VENTILATION), REDUCE WIPER SPEED SETTING, SWITCH FROM HEADLIGHTS TO RUNNING LIGHTS, ALL TO REDUCE ELECTRICAL LOAD. I THEN NOTICE THAT THE POWER STEERING HAS FAILED. IT WAS REALLY SCARY. TRUE FEAR. THE FEAR WHICH WE DO NOT OFTEN ENCOUNTER. I SAFELY GOT THE VEHICLE OFF THE FREEWAY. NO FURTHER FAILURE OF SYSTEMS. I DROVE THE VEHICLE TO THE NEAREST SHOP I KNEW OF, WITH CAUTION LIGHTS ON. I THERE LEARNED THAT THE ACCESSORY BELT HAD COME OFF OF THE ENGINE, DUE TO THE RAIN. THE BELT WAS STILL IN GOOD CONDITION, SO THEY...

AFTER DRIVING THROUGH A SMALL WATER PUDDLE I LOST POWER STEERING AND GENERATOR. IT WAGON A WINDY MOUNTAIN ROAD AND WAS VERY HAZARDOUS AS IT LEFT USONA BLIND CURVE IN THE RAIN. IT TURNED OUT THAT THE DRIVE BELT HAD COME OFF. IS APPEARS TO BE A COMMON AN KNOWN ISSUE WITH CHRYSLER. *TR

SERPENTINE BELT SLIPS OFF IN THE RAIN CAUSING A LOSS IN POWER STEERING, AC (FOR WINDOW DEFOGGING), POWER (NO ALTERNATOR WHEN HEADLIGHTS ARE ON DURING RAIN). WHEN IT SLIPPED OFF, THE ABILITY TO CORRECT FOR LOSS OF TRACTION DUE TO WATER WAS REDUCED DUE TO LACK OF POWER STEERING AND THE WINDSHIELD FOGGED UP QUICKLY DUE TO THE LOSS OF THE AC COMPRESSOR. SLID OF THE INTERSTATE AND SLID DOWN THE MEDIAN. MULTIPLE OTHER INSTANCES OF BELT SLIPPING OFF (4 TIMES IN PAST 3 DAYS), THOUGH AT LOWER RATES OF SPEED. DODGE DENIES THERE IS AN ISSUE EVEN THOUGH THERE ARE MANY REPORTS ON THE INTERNET RELATING TO THIS PROBLEM. IT IS ALSO INTERESTING THAT THEY NOW SELL A UPGRADE KIT THAT CHANGES OUT THE TWO NON-GROOVED PULLEYS FOR GROOVED ONES AND ADD A BELT WITH GROOVES ON BOTH SIDES. THEY SAID THAT THEY WOULD ONLY FIX THIS PROBLEM WHEN...

PURCHASED USED 2000 CARAVAN W/90,000 MILES. WARRANTY EXPIRED IN 2003 AND BECAUSE OF MILEAGE. PROBLEM: BELT SLIPS OFF WHEN IT RAINS, CAUSING POWER STEERING TO NOT WORK, MECHANIC SAYS IT CAN DESTROY ENGINE IF YOU CONTINUE TO DRIVE W/BELT OFF. HAD BELT PUT BACK ON 5 TIMES. WON'T DRIVE WHEN IT'S WET OUT, PLAN TO PURCHASE THIS "KIT" NEEDED IN ORDER TO STOP BELT SLIPPING OFF. KIT IS EST. $600, PLUS LABOR COST. I KEEP WONDERING WHAT DID PRIOR OWNER DO FOR THIS PROBLEM. *TR

I HAVE 2000 DODGE CARAVAN WITH A 3.0L ENGINE. EVERY TIME IT RAINS OR SNOWS THE SERPENTINE BELT COMES OFF. THIS CAUSES THE POWER STEERING TO LOCK UP, AND THE ALTERNATOR TO STOP CHARGING. THE CAR IS ALMOST IMPOSSIBLE TO STEER. YOU LOSE CONTROL. THE MALFUNCTION WAS CORRECTED USING THE GATES MICRO V KIT. THIS INCLUDES A RIBBED BELT TENSIONER, RIBBED IDLER AND A DOUBLE SIDE SERPENTINE BELT. *TR

THE SERPENTINE BELT COMES OFF OFTEN , MORE WHEN DRIVEN OVER A PUDDLE OF WATER. MORE OFTEN IN WET WEATHER. IT'S SCARY TO DRIVE ON THE HIGHWAY AND THE BELT COMES OFF YOU LOSE POWER STEERING AUTOMATICALLY AND ALL YOUR OTHER FACTION. IT'S STARTED ABOUT YEAR AFTER GETTING VAN. *TR

TL*THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING AND TURNING THE STEERING WHEEL IT SEEMED AS IF THE POWER STEERING MALFUNCTIONED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MECHANIC ADVISED HER THAT THE TENSION AND IDLE PULLEY FAILED AND NEEDED TO BE REPLACED. FURTHERMORE, SHE NOTICED A SQUEAKING NOISE WHICH SHE PRESUMED WAS IN THE BRAKE AREA WHEN THE BRAKES WERE ENGAGED AND OCCASIONALLY FAILED TO STOP THE VEHICLE. SHE SPOKE WITH A REPRESENTATIVE WHERE SHE PURCHASED THE VEHICLE; HOWEVER, HE TEST DROVE THE VEHICLE AND ADVISED HER THAT THERE WERE NO PROBLEMS WITH THE BRAKES. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER OR AN AUTHORIZED DEALER HAVE NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 138,830. UPDATED 4/30/10 *CN TRANSMISSION FLUID WAS LEAKING. UPDATED 06/28/10*JB

2000 DODGE CARAVAN - BELT KEEPS COMING OFF DURING RAIN/SNOW -- THIS EFFECTS THE POWER STEERING MAKING THE VAN VERY HARD TO STEER --- WE HATE DRIVING IT WHEN IT'S DOING TO RAIN/SNOW -- THIS IS SUPPOSED TO BE A FAMILY VAN ---- MAKE DODGE FIX IT --- SO FAR THEY DON'T HAVE A SOLUTION TO THE PROBLEM BUT INSTALLING NEW BELTS/TENSIONER --- WHICH EVERY 2-3 WEEKS IS EXPENSIVE ALONG WITH TOWS --- PLEASE HELP! *TR

TL* - THE CONTACT STATED THAT WHILE DRIVING THE 2000 DODGE CARAVAN AT 25 MPH AND THEN YIELDING TO MAKE A RIGHT TURN THE VEHICLE BEGAN TO MAKE A SWOOSHING NOISE AND THEN THE STEERING WHEEL WAS DIFFICULT TO TURN AND THE BATTERY LIGHT TURNED ON. THE CONTACT MANEUVERED THE VEHICLE INTO A PARKING LOT. THE CONTACT HAD THE VEHICLE TOWED BECAUSE IT WAS HARD TO STEER AND THE BATTERY LIGHT WAS ON. *AK UPDATED 03/19/07.*JB

I WAS DRIVING 200 CARAVAN ON A SURFACE STREET IN BUSY TRAFFIC. THE SERPENTINE BELT SLIPPED OFF AND I WAS LEFT WITH NO POWER STEERING. THERE WAS NO WARNING UNTIL I HAD TO TURN. I PUT THE BELT BACK ON AND LATER THAT EVENING IN THE RAIN THE BELT SLIPPED OFF AGAIN. AT THIS TIME IT WAS DARK AND I WAS ON A HIGHWAY. I REPLACED THE BELT WITH AN OLD SPARE I KEEP IN THE VAN AND I MADE IT HOME. *JB

THE SERPENTINE BELT HAS COME OFF MY VAN 5 TIMES IN THE LAST 6 MONTHS. THIS IS A FAMILY VAN AND DRIVEN DAILY WITH 5 CHILDREN IN IT. THIS IS A COMPLAINT OF MANY CARAVAN OWNERS. THERE ARE SITES ALL OVER THE INTERNET COMPLAINING ABOUT THIS PROBLEM.

DT: CONSUMER'S WIFE WAS DRIVING WITH HER 2 LITTLE GIRLS. STOPPED AT A RED LIGHT BRAKES FAILED AND STEERING LOCKED UP. WENT OFF THE ROAD INTO A PARKING LOT AND HIT TREE. THE VEHICLE WAS TOWED AND THE MECHANIC SAID THERE WERE NO BRAKES IN THE VAN. *AK VAN. UPDATED 3/20/2006 - *NM

THE BRAKE MASTER CYLINDER FAILED, THE BRAKE LINE LEAKED, THE TRANSMISSION MALFUNCTIONED, THE FRONT AXLE AND CALIPER PADS/ROTORS BROKE SPILLING BALL JOINT INTO THE STREET. *BF THERE WERE ALSO SCREECHING SOUNDS, ODOR(S), VIBRATIONS, THE STEERING WHEEL DID NOT FUNCTION PROPERLY, AND THE A/C FAILED.

THE STUD THAT FASTENS THE MAIN BELT TENSIONER/ IDLER BROKE DUE TO METAL FATIGUE, CAUSING COMPLETE LOST OF POWER STEERING AND CONTROL OF THE MINIVAN. LOCAL DEALER PARTS DEPARTMENT TOLD ME THAT HE SELLS A LARGE NUMBER OF THESE DUE TO FAILURE AND "KNEW THAT PART NUMBER BY HEART" PLS INVESTIGATE THESE STUDS SHOULD NOT FAIL DUE TO FATIGUE AND THE RESULTING LOST OF CONTROL IS EXTREMELY DANGEROUS THE VEHICLE IN QUESTION IS A 200 DODGE GRAND CARAVAN. *JB

THE SERPINTINE BELT JUST CAME OFF MY 2000 DODGE CARAVAN. MADE IT VERY DIFFICULT TO DRIVE, I WAS ONLY TRAVELING 20 MPH AT THE TIME AND WAS LUCKY THAT THE BELT DID NOT WRAP AROUND ANY OF THE COMPONENTS.

CONSUMER STATES WHILE PARKING AND WITHOUT ANY INDICATION VEHICLE LOST STEERING. CONSUMER LOOKED UNDER VEHICLE AND NOTICED STEERING BOLT ON GROUND.*AK

CONSUMER STATED THERE IS A KNOCKING NOISE IN THE STEERING WHEN TURNING HARD AND WHEN TURNING AND NOT MOVING, CONSUMER ALSO COMPLAINED THAT THERE IS VIBRATION IN THE STEEING, DEALER BALANCED FRONT TIRES FROM A PREVIOUS COMPLAINT ABOUT THE STEERING.*JB

CONSUMER STATED THERE IS A KNOCKING NOISE IN THE STEERING WHEN TURNING HARD AND WHEN TURNING AND NOT MOVING, CONSUMER ALSO COMPLAINED THAT THERE IS VIBRATION IN THE STEEING, DEALER BALANCED FRONT TIRES FROM A PREVIOUS COMPLAINT ABOUT THE STEERING.*JB

STEERING SEIZED. SERVICE DEPARTMENT INDICATED THAT THE "RACK AND PINION WAS BINDING". THERE WERE NO INCIDENTS OR ACCIDENTS PRIOR TO THIS OCCURRENCE THE VEHICLE HAS ALWAYS BEEN GARAGED AND WELL MAINTAINED. THE INABILITY TO STEER AT SPEEDS, OTHER THAN PARKING SPEEDS, COULD HAVE CAUSED AN ACCIDENT. AS THIS STEERING FAILURE IS SPONTANEOUS, AND THE ETIOLOGY UNKNOWN, IT SHOULD BE INVESTIGATED. THANK YOU FOR YOUR ATTENTION TO THIS MATTER. SINCERELY, DR. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).