2003 DAMON CHALLENGER — Problems, Recalls & Safety Data
N/A
Safety Rating
7
Owner Complaints
4
Recalls
0
Service Bulletins
0
Investigations
Overview of the 2003 DAMON CHALLENGER
The 2003 DAMON CHALLENGER has received a total of 7 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 4 recall campaigns affecting this vehicle, covering issues with SERVICE BRAKES, HYDRAULIC, EQUIPMENT:RECREATIONAL VEHICLE/TRAILER, SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP. The most commonly reported problems involve the Unknown Or Other (2 complaints), Visibility (2 complaints), and Fuel System Gasoline (1 complaint).
Recalls for the 2003 DAMON CHALLENGER
NHTSA has recorded 4 recalls for the 2003 DAMON CHALLENGER, potentially affecting up to 31,904 vehicles.
Recall 09V225000 — SERVICE BRAKES, HYDRAULIC
| 2,415 vehicles affected
Defect: DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
View full details →Recall 07V130000 — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
| 25,128 vehicles affected
Defect: CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE...
View full details →Recall 03V080000 — SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP
| 2,656 vehicles affected
Defect: CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION IS BEGAN MAY 12, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE...
View full details →Recall 06V132000 — ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
| 1,705 vehicles affected
Defect: CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, "CONTROLS AND DISPLAYS" AND NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO...
Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.
Remedy: DAMON IS WORKING WITH WORKHORSE TO CONTACT THE OWNERS AND REMEDY THIS CAMPAIGN . WORKHORSE WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR DAMON AT 1-800-860-3812.
View full details →Owner Complaints for the 2003 DAMON CHALLENGER
7 complaints have been filed with NHTSA for the 2003 DAMON CHALLENGER. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Unknown Or Other | 2 | 0 | 0 | 0 | 0 |
| Visibility | 2 | 0 | 0 | 0 | 0 |
| Fuel System Gasoline | 1 | 0 | 0 | 0 | 0 |
| Service Brakes Hydraulic | 1 | 0 | 0 | 0 | 0 |
| Structurebodydoor | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
TL*THE CONTACT OWNS A 2003 DAMON CHALLENGER, WORKHORSE RECREATIONAL VEHICLE. SHE RECEIVED A RECALL LETTER PERTAINING TO THE FAILURE (SEE NHTSA CAMPAIGN ID NUMBER: 09V225000, NHTSA ACTION NUMBER: EA07016, COMPONENT: SERVICE BRAKES, HYDRAULIC) AND TOOK THE VEHICLE TO THE NEAREST AUTHORIZED DEALER. BEFORE ANY REPAIR WORK WAS PERFORMED ON THE VEHICLE THE DEALER STATED THAT THE REPAIR WAS AT NO COST; HOWEVER, THE DEALER ADVISED HER THAT THE VEHICLE WAS READY FOR PICK-UP. THE REPAIRS COST WAS OVER $800 AND WOULD NOT BE COVERED BY THE MANUFACTURER DESPITE THE FACT THAT HER SPECIFIC RV WAS A PART OF THE RECALL. THE WORKHORSE DEALER WOULD NOT COVER THE INSPECTION TO THE VEHICLE NOR THE REPLACEMENT OF ANY PARTS SINCE THE PARTS ARE SUBJECT TO WEAR. THE MANUFACTURER WAS CONTACTED AND VERIFIED THAT THERE WAS AN OPEN RECALL ON THE VEHICLE; HOWEVER, SHE WAS ADVISED BY THE CUSTOMER SERVICE AGENT THAT SHE NEEDED TO SPEAK WITH THE REGIONAL MANAGER SINCE HE WAS NOT AUTHORIZED TO GIVE HER ANY ADDITIONAL INFORMATION PERTAINING TO THE ISSUE. THE CONTACT WAS UPSET THAT SHE WAS BEING CHARGED FOR COMPONENTS AND INSPECTIONS LISTED IN THE RECALL. THE RECALL WAS NOT HONORED. REPAIRS WERE MADE TO THE BRAKES, BRAKE PADS, A FLUSH WAS PERFORMED AND AN INSPECTION, ALL OF WHICH WERE AT THE OWNERS EXPENSE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 33,000.
STALLING WHEN IT RAINS. IT SEEMS THAT THE AIR FILTER IS RIGHT IN FRONT OF THE RIGHT FRONT WHEEL. WHEN IT RAINS THE FRONT TIRE KICKS UP WATER IN THE AIR FILTER HOUSING SOAKING THE AIR FILTER CAUSING THE ENGINE TO QUIT RUNNING. THIS HAPPENS EVERY TIME IT RAINS HARD. I HAVE TO REPLACE THE FILTER IN ORDER TO CONTINUE DRIVING. CARRYING EXTRA AIR FILTERS IS STARTING TO GET EXPENSIVE. RIGHT NOW I USE DUCK TAPE TO SEAL THE FILTER BOX. *NM
SUN VISORS CAN NOT BE REACHED WHILE SITTING. I HAVE TO PULL OVER TO THE SIDE OF THE ROAD TO ADJUST. AT TIMES THIS IS REAL DANGERIOUS SINCE MOST OF THE HIGHWAYS DO NOT HAVE PLACES WIDE ENOUGH TO ALLOW THIS. THIS PROBLEM HAPPENS ALL THE TIME, REAL BAD WHEN YOU ARE TRAVELING TO THE WEST.*AK
THE CONSUMER IS CONCERNED ABOUT THE SUN VISORS ON THE MOTOR HOME. WHILE DRIVING, THE DRIVER HAD TO UNBUCKLE THE SEAT BELT AND STAND UP TO REACH THE SUNVISOR. ONCE THE VISOR WAS PULLED DOWN IT WAS TOO SHORT TO BLOCK THE GLARE OF THE SUN AND AS A RESULT THE DRIVER COULD NOT SEE WHILE DRIVING. *NM
INSIDE COMPARTMENT DOORS DON'T HAVE SUPPORT, THIS IS SAFETY A SAFETY ISSUE THEY WERE NOT WELL DESIGNED. DEALER NOTIFIED. *AK
Safety Rating for the 2003 DAMON CHALLENGER
NHTSA has not yet tested the 2003 DAMON CHALLENGER in its New Car Assessment Program.
Technical Service Bulletins for the 2003 DAMON CHALLENGER
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2003 DAMON CHALLENGER
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the DAMON CHALLENGER
- 1998 DAMON CHALLENGER — 10 complaints
- 1999 DAMON CHALLENGER — 7 complaints
- 2000 DAMON CHALLENGER — 4 complaints
- 2001 DAMON CHALLENGER — 1 complaint
- 2002 DAMON CHALLENGER — 3 complaints
- 2003 DAMON CHALLENGER (current)
- 2004 DAMON CHALLENGER — 2 complaints
- 2005 DAMON CHALLENGER — 2 complaints
- 2006 DAMON CHALLENGER — 4 complaints
- 2007 DAMON CHALLENGER — 2 complaints
- 2008 DAMON CHALLENGER — 4 complaints
Other DAMON Models
- DAMON INTRUDER — 47 total complaints
- DAMON DAYBREAK — 45 total complaints
- DAMON DAMON — 35 total complaints
- DAMON ESCAPER — 16 total complaints
- DAMON ULTRASPORT — 16 total complaints
- DAMON OUTLAW — 6 total complaints
- DAMON ASTORIA — 5 total complaints
- DAMON AVANTI — 5 total complaints