1996 CHEVROLET VAN — Problems, Recalls & Safety Data
N/A
Safety Rating
46
Owner Complaints
0
Recalls
0
Service Bulletins
0
Investigations
Overview of the 1996 CHEVROLET VAN
The 1996 CHEVROLET VAN has received a total of 46 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). The most commonly reported problems involve the Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip (11 complaints), Service Brakes Hydraulicfoundation Componentsdisc (3 complaints), and Suspensionfrontspringstorsion Bar (3 complaints).
Recalls for the 1996 CHEVROLET VAN
There are no recalls on file with NHTSA for the 1996 CHEVROLET VAN. No Active Recalls
Owner Complaints for the 1996 CHEVROLET VAN
46 complaints have been filed with NHTSA for the 1996 CHEVROLET VAN. Below is a breakdown by vehicle component.
Most Recent Complaints
DT*: THE CONTACT STATED THE HARNESS THAT CONNECTS THE POWER TO THE TOP OF THE FUEL PUMP FAILED CAUSING ARCING THAT BURNS THE CONNECTOR. THIS MELTED THE PLASTIC ON THE INSIDE OF THE FUEL TANK AND THE VEHICLE STALLED. THE DEALERSHIP DETERMINED THE FUEL PUMP NEEDED TO BE REPLACED. TWO FUEL PUMPS WERE INSTALLED. AFTER THE SECOND FUEL PUMP WAS INSTALLED, THE DEALERSHIP DETERMINED THE CONNECTOR WAS BAD.
DT*: THE CONTACT STATED THAT THERE WAS GASOLINE SPILLING OUT OF THE FILLER NECK OF THE REAR FUEL TANK. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER DETERMINED THAT THE PUMP IN THE REAR TANK FAILED. THE VEHICLE WAS NOT REPAIRED AT THAT TIME. THERE IS A NHTSA RECALL # 93V125000, PERTAINING TO THE FUEL TANK ASSEMBLY HOWEVER THE VIN WAS NOT INCLUDED IN THE RECALL.
DT: THE CONSUMER STATED THE HEADLIGHTS WERE BLINDING TO OTHER VEHICLES. THE HEADLIGHTS HAVE BEEN ADJUSTED NUMEROUS TIMES AND HAVE BEEN REPLACED ABOUT 10 TIMES.*AK
2 MULTI PORT INJ 1INTAKE MANIFOLD GASKET
2 MULTI PORT INJ 1INTAKE MANIFOLD GASKET
View all Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip complaints →
Safety Rating for the 1996 CHEVROLET VAN
NHTSA has not yet tested the 1996 CHEVROLET VAN in its New Car Assessment Program.
Technical Service Bulletins for the 1996 CHEVROLET VAN
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 1996 CHEVROLET VAN
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET VAN
- 1991 CHEVROLET VAN — 4 complaints
- 1992 CHEVROLET VAN — 12 complaints
- 1993 CHEVROLET VAN — 19 complaints
- 1994 CHEVROLET VAN — 11 complaints
- 1995 CHEVROLET VAN — 31 complaints
- 1996 CHEVROLET VAN (current)
- 1997 CHEVROLET VAN — 41 complaints
- 1998 CHEVROLET VAN — 18 complaints
- 1999 CHEVROLET VAN — 19 complaints
- 2000 CHEVROLET VAN — 36 complaints
- 2001 CHEVROLET VAN — 22 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints