2005 CHEVROLET UPLANDER Suspension Problems

WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF THE VEHICLE WAS TRACKING SIDEWAYS. THANK GOD NOTHING BAD HAPPENED, WE HAD ALL SIX OF OUR KIDS WITH US WHEN IT WENT OUT AT 75MPH.

2005 CHEVY UPLANDER LT. UNDERCARRIAGE RUSTED ON BACK PASSENGER SIDE WITHIN 9 MONTHS AFTER PURCHASE, CAUSING SEPARATION OF THE REAR PASSENGER WHEEL FROM THE BODY OF VEHICLE. WHEN DRIVING, YOU CAN HEAR/FEEL CLUNKING/SQUEAKING NOISE WHICH SOUNDS LIKE THE TIRE IS GOING TO COME COMPLETELY OFF THE CAR. AREA AFFECTED CANNOT BE REPLACED NOR WELDED AS THIS CAN BE UNSAFE TO DRIVE. I HAVE IMAGES THAT CAN BE SENT VIA EMAIL.

TAMARA RECALL AS I WAS DRIVING WITH MY WHOLE FAMILY IN OUR VAN, THE LEFT TRAILING ARE BROKE OFF. THEREFORE, MY AXLE STARTED TO FALL OFF. I COULD NOT STOP US. MY BREAKS DIDN'T WORK, SINCE IT SNAPPED MY BREAK LINE TOO. I WAS ONLY GOING 25MPH. ONCE WE CAME TO A STOP, WE GOT OUT, AND MY LEFT BACK TIRE WAS UNDER MY BUMPER.

TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE DRIVING 45 MPH, THE CONTACT NOTICED AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRAILING ARM OR THE TRAILING ARM BUSHING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V110000 (SUSPENSION). THE FAILURE MILEAGE WAS 100,000. UPDATED 05/26/16*LJ

ON DECEMBER 15, 2011, A 2005 CHEVROLET UPLANDER WAS DRIVEN ON A SIDE STREET AT APPROXIMATELY 25 MPH. WITHOUT WARNING, THE WHEEL JERKED OUT OF THE DRIVER'S HAND AND THE VEHICLE STRUCK A PARKED VEHICLE AND CAME TO A STOP. NO ONE WAS INJURED. A FORENSIC ENGINEERING INVESTIGATION REVEALED THAT THE FAILURE OF THE RIGHT STEERING KNUCKLE WAS THE SOLE CAUSE OF THIS INCIDENT. THE PART NUMBER ON THE FRONT OF THE BOTTOM PORTION OF THE STEERING KNUCKLE IS "INTERMEDIATE 0472 98 U/W R". THE CASTING NUMBER ON THE REAR OF THE BOTTOM PORTION OF THE STEERING KNUCKLE IS "0800 561 220". NHTSA CAMPAIGN ID NUMBER: 09E005000 REFERS TO FAILURE OF STEERING KNUCKLES MANUFACTURED BY DORMAN PRODUCTS, INC. THIS RECALL STATES THAT, "A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA." THE HUB AREA IS ALSO THE AREA WHERE THE INTERMEDIATE STEERING...

THE ABS LIGHT ON THE VEHICLE CAME ON WHILE DRIVING. THE LIGHT STARTED GOING ON AND OFF REGULARLY SO THE VEHICLE WAS BROUGHT IN TO THE DEALER FOR SERVICE. THE DEALER SAID THE FRONT WHEEL HUB BEARINGS NEEDED TO BE REPLACED BUT THESE WERE NOT COVERED UNDER WARRANTY. BOTH FRONT WHEEL HUB BEARINGS WERE REPLACED AT OUR OWN EXPENSE BUT THEN THE LIGHT STARTED GOING ON AND OFF AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THIS TIME THEY SAID THE COMPUTER & WIRING SYSTEM WAS BAD AND NEEDED TO BE REPLACED. THE DEALER ALSO INDICATED THAT THIS HAD BEEN A RECURRING PROBLEM ON THIS MODEL BUT NOT ENOUGH CONSUMERS WERE AFFECTED TO GENERATE A RECALL SO WE WOULD HAVE TO PAY FOR THIS REPAIR OURSELVES AS WELL. THE DEALER HAS INSTRUCTED US THAT IT IS DANGEROUS TO OPERATE THE VEHICLE UNTIL THE REPAIRS ARE MADE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE ATTEMPTING TO CLOSE THE PASSENGER SIDE DOOR, THE ALERT BELL BEGAN TO RING AND THE DOOR FAILED TO SHUT. THE CONTACT HAD TO PUSH THE BUTTON TO RELEASE THE DOOR. ONCE THE DOOR OPENED, IT WAS FINALLY ABLE TO BE CLOSED. THE VEHICLE'S HORN DOES NOT WORK. IN ADDITION, THE STARTER IS BAD. WHEN THE CONTACT TURNS THE IGNITION, THE VEHICLE FAILS TO START. SHE MUST DEPRESS THE ACCELERATOR PEDAL AFTER TURNING THE IGNITION IN ORDER FOR IT TO START. THE RIGHT WINDOW REMAINS OPEN WHEN ATTEMPTING TO CLOSE IT WITH THE OVERHEAD BUTTON. THE DEALER HAS REPAIRED THE VEHICLE, BUT THE FAILURE PERSISTS. WHEN MAKING A LEFT TURN, THE CONTACT HEARS A NOISE COMING FROM THE SUSPENSION. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 18,000 AND FAILURE MILEAGE WAS 12. THE CONSUMER STATED WATER NOW LEAKS INTO THE VEHICLE...

DT*: THE CONTACTED STATED THE VEHICLE MAKES NOISE AND VIBRATES EXCESSIVELY WHEN PRESSING THE ACCELERATOR PEDAL OR TURNING THE STEERING WHEEL TO THE LEFT AND RIGHT. VEHICLE SPEED DOES NOT AFFECT THE SOUND OR VIBRATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER SEVERAL TIMES FOR INSPECTION. THE LOCAL DEALER NEVER DIAGNOSED THE PROBLEM. SO THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC FOUND THE FOLLOWING PROBLEMS WITH THE VEHICLE AND NOTED THEM ON A SERVICE INVOICE "RUB MARKS ON THE LEFT DRIVE AXLE, THE REAR MOTOR MOUNT IS NOT HOLDING THE ENGINE SOLID AND THE ENGINE IS MOVING EXCESSIVELY ON THE CRADLE." THE INDEPENDENT MECHANIC SUSPECTS THE CASTER OR CAMBER MAY BE OUT CAUSING OUTER TIRE WEAR ON BOTH THE PASSENGER AND DRIVER SIDE TIRES. THE INDEPENDENT REPAIR SHOP ONLY INSPECTED THE VEHICLE AND THEY NEVER MADE ANY REPAIRS, AS THE VEHICLE WAS...