2004 CHEVROLET SUBURBAN Structurebody Problems
2 NHTSA complaints on file
Structurebody Issues in the 2004 CHEVROLET SUBURBAN
2 structurebody complaints have been filed with NHTSA for the 2004 CHEVROLET SUBURBAN. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Structurebody Complaints
TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE SHIFTING GEARS, THERE WAS AN ABNORMAL CLUNKING SOUND COMING FROM UNDERNEATH THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THERE WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 238,239.
THE REAR WINDOW LIFT HINGE ATTACHED TO THE GLASS TO THE TAILGATE IS DEFECTIVE. AFTER RESEARCHING THIS HINGE ONLINE, I LOCATED SEVERAL WITH THE SAME PROBLEM. THIS COULD CAUSE SEVERAL PROBLEMS IF THE GLASS WERE TO SEPARATE DURING TRAVEL AND SHOULD BE A HUGE SAFETY CONCERN FOR CHEVROLET. THE ESTIMATED REPAIR COST IS $1,300.00 FOR A DEFECTIVE PART THAT WILL JUST RE-OCCUR WITH IN A FEW YEARS AS SOME OF THE COMPLAINANTS OBSERVED ONLINE BY NEW OWNERS OF 2 YEARS. THIS PART IS DEFECTIVE AND NOT DUE TO NORMAL WEAR AND TARE. *TR
Other 2004 CHEVROLET SUBURBAN Problem Areas
Electrical System Instrument Clusterpanel
41 complaints
Service Brakes
32 complaints
Electrical System
25 complaints
Vehicle Speed Control
11 complaints
Steering
10 complaints
Service Brakes Hydraulic
9 complaints
Electronic Stability Control Esc
8 complaints
Air Bags
7 complaints
Fuel System Gasolinedeliveryfuel Pump
7 complaints
Power Trainautomatic Transmission
7 complaints
Engine
6 complaints
Fuel System Gasoline
5 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
5 complaints
Suspension
5 complaints
Electrical Systemwiring
4 complaints
Engine And Engine Cooling
4 complaints
Unknown Or Other
4 complaints
Air Bagsfrontal
3 complaints
Engine And Engine Coolingengine
3 complaints
Seats
3 complaints
Tires
3 complaints
Air Bagssidewindow
2 complaints
Electrical Systemignitionswitch
2 complaints
Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe
2 complaints
Equipment
2 complaints
Equipmentapplianceair Conditioner
2 complaints
Latcheslockslinkages
2 complaints
Power Train
2 complaints
Power Traintransfer Case 4 Wheel Drive
2 complaints
Seat Beltsfrontanchorage
2 complaints
Steeringhydraulic Power Assist System
2 complaints
Suspensionfront
2 complaints
Visibility
2 complaints
Visibilitypower Window Devices And Controls
2 complaints
Visibilitywiper
2 complaints
Air Bagsfrontalsensorcontrol Module
1 complaint
Engine And Engine Coolingcooling System
1 complaint
Engine And Engine Coolingenginegasoline
1 complaint
Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor
1 complaint
Equipment Adaptivemobility
1 complaint
Equipmentrecreational Vehicletrailer
1 complaint
Exterior Lighting
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Fuelpropulsion System
1 complaint
Power Trainautomatic Transmissioncontrol Module Tcmpcmtecm
1 complaint
Power Traindrivelineuniversal Joint
1 complaint
Power Trainmanual Transmission
1 complaint
Seatsfront Assemblypower Adjust
1 complaint
Seatsmidrear Assembly
1 complaint
Service Brakes Airantilockwheel Speed Sensor
1 complaint
Service Brakes Hydraulicfoundation Components
1 complaint
Service Brakes Hydraulicfoundation Componentshoses Linespiping And Fittings
1 complaint
Service Brakes Hydraulicfoundation Componentsmaster Cylinder
1 complaint
Service Brakes Hydraulicpower Assisthydraulic
1 complaint
Steering Steering Wheelhandle Bar
1 complaint
Steeringcolumn Lockinganti Theft Device
1 complaint
Steeringgear Boxshaft Pitman
1 complaint
Structure
1 complaint
Tirestemporaryemergency Spare Tire
1 complaint
Tirestreadbelt
1 complaint
Traction Control System
1 complaint
Vehicle Speed Controllinkages
1 complaint
Visibilityglass Siderear
1 complaint
Visibilityrear Window Wiperwasher
1 complaint
Visibilityrear Window Wiperwasherswitchwiring
1 complaint
Visibilityrearview Mirrorsdevicesexterior
1 complaint
Wheels
1 complaint