2011 CHEVROLET SILVERADO Fuelpropulsion System Problems

FIRST OF THREE VEHICLE COLLISIONS THIS YEAR INVOLVING CHEVROLET SILVERADOS THAT HAVE CAUGHT FIRE AFTER INVOLVED IN FRONTAL IMPACTS. VEHICLE TRAVELING WESTBOUND ON SR 58 IN LANE COUNTY, OREGON. INVOLVED IN SECONDARY COLLISION WITH A TOYOTA PICKUP TRUCK THAT HAD BEEN STRUCK BY A LOOSE TRUCK TRACTOR WHEEL. THE IMPACT BY THE WHEEL CAUSED THE TOYOTA TO ENCROACH INTO THE PATH OF THE CHEVROLET. THE OCCUPANTS OF CHEVROLET WERE ABLE TO EXTRICATE THEMSELVES. THE VEHICLE SUBSEQUENTLY CAUGHT FIRE AND SUFFERED EXTENSIVE FIRE DAMAGE.

TL* THE CONTACT OWNS A 2011 CHEVROLET SILVERADO. WHILE ATTEMPTING TO START THE VEHICLE, IT WOULD HESITATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS NOT AVAILABLE. UPDATED 09/17/15*LJ UPDATED 11/28/2017*CN

ON OCT 4TH, 2014 I WAS TRAVELING FROM SAN ANGELO, TX TO SAN ANTONIO, TX, IN MY 2011 3500 CHEVROLET DIESEL PICKUP, PULLING OUR 5TH WHEEL CAMPER. WHEN I NEARED JUNCTION, TX I COULD SMELL AN ODOR OF FUEL. ON I-10 EB MILE 456, I NOTICED THAT MY FUEL GAUGE WAS RAPIDLY DROPPING. WHEN I LEFT JUNCTION, THE GAUGE READ HALF FULL. AT MILE MARKER 497, I PULLED INTO A REST STOP, BECAUSE THE FUEL GAUGE HAD DROPPED TO THE EMPTY MARK. I GOT OUT OF THE TRUCK AND COULD SEE THE DIESEL POURING OFF THE BOTTOM OF THE MOTOR. WHEN THE DRIPPING STOPPED I ATTEMPTED TO START THE TRUCK, BUT IT WOULD NOT START. THE STARTER MOTOR WAS RUNNING, BUT THE FUEL TANK WAS COMPLETELY EMPTY. IN THAT DISTANCE THE TRUCK SHOULD HAVE USED FIVE GALLONS OF DIESEL PULLING THE TRAILER. WHICH MEANS THAT ABOUT 14 GALLONS WERE DUMPED...

TANK WAS FILLED TO LESS THAN 1/2 TANK AND AFTER STOPPING AT LOCATION AND RESTARTING VEHICLE. FUEL LEVEL READ EMPTY. FUEL LEVELS AND COMPUTER SYSTEM NOT ACCURATE. MULTIPLE OCCURRENCES. I DID SPEAK WITH THE DEALERSHIP AND THEY "THINK" IT COULD BE THE FUEL PUMP. IT HAS BEEN DOING THIS SINCE THE INITIAL PURCHASE. NEW VEHICLE STATUS. *TR

ONCE THE VEHICLE IS IN PARK IT IS SITTING UP AND AFTER PUTTING THE VEHICLE IN REVERSE AND STARTING TO DRIVE THE VEHICLE LOWERS TO THE GROUND. THE VEHICLE PULLS WHEN DRIVING AND CAUSES AN ADDITIONAL PULL ON THE ENGINE AND FUEL SYSTEM. *TR

AT 36000 MILES THE ENGINE BURNS OIL. SO FAR AS OF 46000 MILES PISTONS BURNED HAVE BEEN REPLACED PVC FILTER AND VALVE WERE REPLACED ALONG WITH VALVE COVER. AT PRESENT 54000 MILES ENGINE STILL BURNS OIL. *TR

TL* THE CONTACT OWNS A 2011 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE FUEL TANK WAS FILLED WITH UREA SPECIAL FUEL FOR DIESEL TRUCKS. THE CONTACT WAS DRIVING 5 MPH, WHEN THE VEHICLE UNEXPECTEDLY DECELERATED FROM 55 TO 5 MPH WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER AND THE MECHANIC STATED THAT THE HEATER IN THE UREA TANK HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 59,000.

EVERYTIME I GO TO THE PUMP IT KICKS OUT LIKE THE TANK IS FULL. IF YOU HOLD THE NOZZLE AS ITS BARELY COMING OUT IT WILL WORK NORMAL BUT YOU CANT EVEN USE THE LOWEST NOTCH ON THE PUMP TO SET IT ON TO PUMP GAS, IT WONT WORK. SO IT NEEDS TO BE FIXED AND I'VE TOLD THE CHEVY DEALER ABOUT IT AND THEY SAID THERE IS NOTHING WRONG WITH IT AND NO RECALL. IM TRYING TO MAKE IT A RECALL NOW SO IT WILL BE FIXED. *TR