2003 CHEVROLET SILVERADO Engine And Engine Cooling Problems

11 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Engine And Engine Cooling Issues in the 2003 CHEVROLET SILVERADO

11 engine and engine cooling complaints have been filed with NHTSA for the 2003 CHEVROLET SILVERADO. Of these, 0 involved a crash, 2 involved a fire, and 0 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Engine And Engine Cooling Complaints

#10460813 | June 6, 2012 Fire

MY TRUCK HAS BEEN BLOWING HOT AIR WHEN ON COOL. WHEN IT STARTED DOING IT, I NOTICED SPARKS COMING FROM WHAT APPEARED TO BE MY AC UNIT. THIS IS A SAFETY HAZARD. I BELIEVE THAT MY ACTUATOR BLEND DOORS NEED TO BE REPLACED BUT DO NOT KNOW FOR SURE. *TR

#10448993 | February 22, 2012

I HAVE SEVERAL BROKEN BOLTS ON MY EXHAUST MANIFOLDS. MY CHECK ENGINE LIGHT GOES ON AND OFF FOR EMISSIONS RELATED CODES. I WILL NOT BE ABLE TO PASS A SMOG TEST UNLESS THIS IS FIXED. SEVERAL AUTO SHOPS WANT ABOUT $1,000 TO FIX THIS. ITS AN ONGOING PROBLEM AND IS KNOWN BY CHEVY/GM AND YET THEY WILL DO NOTHING TO HELP OR FIX IT. THIS SHOULD BE RECALLED IMMEDIATELY! *TR

#10424185 | September 7, 2011

WHILE IDLING AT A RED LIGHT THE SMELL OF EXHAUST FUMES BECAME PREVALENT INSIDE THE PASSENGER CABIN. UPON INSPECTION OF THE EXHAUST SYSTEM IT WAS DETERMINED 5 OF THE EXHAUST MANIFOLD BOLTS HAD PREMATURELY FAILED ALLOWING EXHAUST GAS TO ESCAPE FROM THE ENGINE INTO THE ENGINE COMPARTMENT AND INTO THE PASSENGER CABIN. THE VEHICLE IS CURRENTLY USED SPARINGLY WHERE FAMILY MEMBERS OR FRIENDS ARE NOT ALLOWED TO RIDE IN THE TRUCK UNTIL THE EXHAUST MANIFOLDS ARE REPAIRED. *TR

#10151112 | February 24, 2006

DT*: THE CONTACT STATED INTERMITTENTLY, WHEN THE OUTSIDE CONDITIONS ARE COLD THE STEERING IS STIFF. THIS OCCURS AT ANY SPEED. THE PROBLEM IS WORSE WHEN THE BRAKE PEDAL IS DEPRESSED AND TURNING THE STEERING WHEEL. THE DEALERSHIP REPLACED THE VALVE IN THE POWER STEERING. THIS HAS NOT CORRECTED THE PROBLEM. THERE IS A TECHNICAL SERVICE BULLETIN, #10013533, REGARDING THIS, BUT NO REPAIR AVAILABLE. THE WATER PUMP GASKET WAS REPLACED. THE TRANSFER CASE BEARINGS WERE REPLACED. UPDATED 03/22/06. *JB

#10133863 | August 23, 2005

A/C STOPS WORKING. PRESSURE SWITCHES CHANGED, COOLENT RECHARGED, NOW THEY ARE ADDING AN ELECTRIC FAN TO HELP COOL THE CONDENSER. CAN'T FIGURE OUT WHAT IS WRONG.

#10099128 | November 1, 2004 Fire

AFTER THE VEHICLE HAD BEEN PARKED FOR A WEEK, A FIRE STARTED UNDER THE HOOD. THE FIRE WAS PUT OUT AND THE DEALERSHIP WAS NOTIFIED. THE PROBLEM WAS NOT RESOLVED. THE CAUSE WAS NOT DETERMINED. *JB *SC

#10087763 | August 12, 2004

THE ENGINE SENSOR CONTINUED TO STAY ON WITHOUT WARNING . THE CONSUMER WAS CONCERNED THAT THE VEHICLE WILL STALL WHILE DRIVING. THE DEALER REPLACED THE FUEL MODULE SEAL, HOWEVER THE PROBLEM STILL CONTINUED. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB *TC

#10070971 | April 22, 2004

FIRST TIME:MAIN COMPUTER FAILED. SECOND TIME:STALLING, RUNNING ROUGH, BOGGS DOWN AND MAKES LOUD NOISE,MIS-FIRE IN #5 & #6 CILANDER.A/C NOT WORKING.NOT FIXED. THIRD TIME: EVERYTHING SAME AS SECOND TIME AND ENGINE LIGHT NOW COMING ON.NOT FIXED. FOURTH TIME:ALL LIGHTS ON DASH COME ON AND ALL MESSAGES APPEARING ON MESSAGE BOARD.NOT FIXED. AFTER COMPUTER CHANGED TRUCK PREFORMED UNSATISFACTORY AND IS STILL UNSATISFACTORY. ALL HAVING TO DO WITH COMPUTER. TOLD IT IS A RANDOM PROBLEM THAT IS HARD TO DETECT AND MAY NOT EVER BE FIXED.

#10066725 | April 7, 2004

WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT WARNING. THIS CAUSED A LOST OF STEERING AND BRAKES. THE VEHICLE HAD BEEN INSPECTED THREE TIMES AND COULD NOT BE REPRODUCED. *AK THE FIRST PROBLEM OCCURRED WHEN THE CONSUMER WAS TRAVELING AT 75 MPH DOWN A SLOPE WHEN THE VEHICLE LOST ALL POWER (ENGINE, BRAKE, AND STEERING) THE CONSUMER WOULD HAVE TO TURN THE SWITCH FOUR TIMES IN ORDER FOR THE ENGINE TO START. THE PROBLEM REPEATED ITSELF TWO MORE TIMES WITH SIMILAR INSTANCES. *SC *JB

#10001839 | January 2, 2003

CONSUMER STATES THE CHECK ENGINE LIGHT COMES ON THEN VEHICLE WOULD SHUT OFF. SOME DAYS THE VEHICLE WOULD RUN ALL DAY WITHOUT SHUTTING OFF DEALER NOTIFIED. TS

#10001730 | December 31, 2002

CONSUMER STATES WHILE DRIVING AND NO WARNING. THE CHECK ENGINE LIGHT WOULD COME ON, THEN THE VEHICLE WOULD SHUT OFF. SOME DAYS THE VEHICLE WOULD GO ALL DAY WITHOUT SHUTTING OFF. CONSUMER STATES SO FAR THE VEHICLE SHUT DOWN 8 TIMES. DEALER NOTIFIED. TS

Other 2003 CHEVROLET SILVERADO Problem Areas

← Back to 2003 CHEVROLET SILVERADO overview