2005 CHEVROLET MALIBU MAXX Electrical System Problems

TAKATA RECALL I WAS DRIVING ON ROUTE 19 JUST BEFORE THE MAPLE FORK EXIT THE LIGHT WAS RED AND I BEGAN TO SLOW DOWN. ALL OF A SUDDEN THE BRAKES AND STEERING WOULD NOT WORK AND THE CAR HIT THE REAR END OF THE CAR IN FRONT OF ME. CAUSING MAJOR DAMAGES TO THE FRONT OF MY CAR. THE OTHER CAR WAS NOT AFFECTED NEARLY AS MUCH. IT WAS LIKE THE CAR JUST STOPPED. NO AIRBAGS WAS DEPLOYED.

WHILE THE CAR IS IN MOTION AND EVEN IN IDLE THE STEERING WHEEL SOMETIMES WILL LOCK. IT HAS HAPPENED WHILE MAKING TURNS, GOING AROUND ROUNDABOUTS, ON THE HIGHWAY, AND ON A REGULAR 15 MIN. WORK COMMUTE. THE CAR WILL BEEP AS IF THE TRUNK IS OPEN. THE BEEPING IS RIGHT BEFORE THE STIFFNESS OF THE STEERING WHEEL. I HAVE TO TURN OFF THE IGNITION AND TURN THE IGNITION BACK ON IN ORDER TO PROCEED IN DRIVING. IF YOU'RE IN MOTION IT'S BEST TO PULL OVER DUE TO THE ENGINE SOMETIMES LAG WHEN TRYING TO START THE CAR BACK UP. ONCE IT IS STARTING, IT DRIVES JUST FINE. I'VE SEEN TONS OF PEOPLE WITH THIS EXACT PROBLEM IN REGARDS TO THIS PARTICULAR VEHICLE. IT COULD CAUSE ACCIDENTS IF OUR STEERING WHEEL LOCKS AND WE'RE UNABLE TO JUST PULL OVER TO SAFETY. SINCE OUR CAR IS MOSTLY ELECTRICAL IT'S NOT AS IF...

IGNITION STAYING STUCK ALOWING STARTER TO CONTINUE TO TURN, DAY TIME NO BREAK LIGHTS , NIGHT TIME BREAK LIGHTS STAY LIT UP OR FLASH ON AND OFF , FUEL GAUGE DROPS TO EMPTY EVEN WHEN FULL BOUNCES BACK AND FORTH EMPTY FULL , SERVICE AIR BAG AND CHECK ENGINE LIGHTS KEEP COMING ON EVEN AFTER THEY HAVE BEEN RESET, CRUISE CONTROL WILL NOT ENGAGE , HARD TIME TO TAKE CAR OUT OF PARK EVEN WITH BRAKE DEPRESSED, LOWER GEARS ON TRANSMISSION WILL NOT ENGAGE INTO 3,2,1 SPEED, DRIVER SEAT BRACKET BROKE IN WELD CAUSING SEAT TO BE UNSTABLE, FAULTY IGNITION SWITCH AND MORE THIS CAR HAS LESS THAN 150 K ON IT 148 AND SOME CHANGE,,, AIR BAG SERVICE LIGHT KEEPS COMING ON AS WELL AS CHECK ENGINE LIGHT, THIS CAR WILL NOT PASS ANY STATE INSPECTION , AND EVEN STATES WITH OUT INSPECTION WOULD ADVISE THAT THE CAR BE...

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHEN THE STEERING WHEEL WAS TURNED TO THE LEFT AND WHEN STARTING THE VEHICLE, AN ABNORMAL NOISE EMERGED FROM THE STEERING WHEEL. THE DEALER WAS NOTIFIED OF THE FAILURE AND INDICATED THAT IT WAS DUE TO A SAFETY FEATURE. IN ADDITION, THE BRAKE LIGHTS REMAINED ILLUMINATED WHEN THE BRAKES HAD NOT BEEN APPLIED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

REGARDING GM RECALL #13036 - MICRO CORROSION ON BCM TERMINALS AND RELEARN - DEALERSHIP CLAIMED THAT RECALL WAS PERFORMED. ISSUES WITH BRAKE LIGHTS AND CRUISE CONTROL REMAIN AFTER RECALL SERVICE. UPON VEHICLE INSPECTION, FOUND THERE WAS NOT AN APPLICATION OF DIELECTRIC GREASE ON C2 TERMINAL PORTS AS DESCRIBED IN THE PROCESS OF THE RECALL. I WAS ABLE TO APPLY THE GREASE MYSELF BUT, I AM UNABLE TO PERFORM THE RELEARN PROCESS WITHOUT THE GM TECH2 TOOL. ATTACHED PICTURES OF C2 CONNECTOR PORT WITH AND WITHOUT DIELECTRIC GREASE. WE WENT BACK TO DEALERSHIP TO TRY AND GET THE RECALL PERFORMED PROPERLY AND THE TECH AT SERVICE DESK STATED THAT THE RECALL WAS SERVICED PROPERLY. MY COMPLAINT IS THAT THE RECALL WAS NOT PERFORMED BY THE DEALERSHIP. ADDRESS: 1820 CAPITAL BLVD, RALEIGH, NC 27604.

I PURCHASED A 2005 MALIBU MAXX FROM AN USED CAR DEALER AND THE VERY NEXT DAY THE CAR LOST THE ABILITY TO ACCELERATE AND THE TRACTION CONTROL LIGHT TURNED ON MY INSTRUMENT CLUSTER. WHILE THE CAR WAS COMING TO A STOP I NOTICED THAT IT LOST ALL POWER AND THE ENGINE STOPPED RUNNING. THE CAR WOULD TURN OVER BUT NOT START.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHILE DRIVING 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT ALSO STATED THAT BOTH TURN SIGNALS FAILED TO FUNCTION. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

UPON ACCELERATION POWER STEERING STOPS WORKING AND POWER STEERING WARNING MESSAGE SHOWS. GM DEALER SERVICE CENTER ADVISED THAT IT IS THE IGNITION COIL. REPLACED WITH A NEWER VERSION OF THE IGNITION COIL AND ADDED A GROUND STRAP BASED ON THE DETECTED ERROR CODES AND A SERVICE BULLETIN FROM GM. UPDATED 10/9/15 *LN UPDATED 11/13/2017*CN

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE KEY ONLY TURNED IN THE IGNITION SWITCH WHEN TURNING AND LIFTING AT THE SAME TIME. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000. UPDATED 3/3/15*CN UPDATED 03/17/15*JB

REPLACED A STEERING ROD AT 34000 & 73000 & 105,000 THAT WAS MADE OF METAL LN 05. GM WENT BACK TO PLASTIC THE NEXT YEAR AS THIS DID NOT HOLD UP. SECOND IS THE REMOTE START PROBLEM. I HAD IT REPAIRED TWO DIFFERENT TIMES AT GM AND DOES NOT WORK AS OF NOW. WAS TOLD IT WAS A BCM PROBLEM EACH TIME.AS IT WAS AN EXPENSIVE FIX TEMPORARY THAT IS.AS MANY OTHER PEOPLE HAVE THE SAME PROBLEM WITH THIS CAR! *TR

TOOK CAR TO THE CHEVROLET DEALERSHIP, FOR NHTSA ID: 14V252000/GM SAFETY RECALL: 13036, TO CORRECT THE ISSUES IN THE BODY CONTROL MODULE WHICH IMPACTED THE BRAKE APPLY SENSOR. NOW REAR TOP BRAKE LIGHTS NO LONGER ILLUMINATE WHEN THE BRAKE PEDAL IS BEING PUSHED. FRONT LOW-BEAM HEADLIGHTS GOES ON AND OFF WHILE DRIVING. REPLACED BOTH LOW-BEAM LIGHTS ON 12/6/2014. FRONT LOW BEAM HEADLIGHTS STILL GOES OFF AND ON INTERMITTENTLY. ALSO UPON VISUAL INSPECTION, THE TURN SIGNAL BLINKERS HAVE MELTED THE YELLOW PLASTIC INSIDE THE HEADLIGHT. BROUGHT BACK TO THE SAME CHEVROLET DEALERSHIP ON 1/2/2015, FOR VEHICLE RECALL NHTSA ID: 14V224000/GM SAFETY RECALL 14152 TO HAVE THE SHIFT CABLE ASSEMBLY AND MOUNTING BRACKET INSTALLED. I NOTIFIED THE DEALERSHIP THAT I WAS HAVING ISSUES WITH THE ELECTRICAL SYSTEM TIED TO THE EXTERIOR LIGHTING SYSTEM. THEY COULD NOT PROVIDE ME THE REASON FOR THE FAULT. *TR

PASSENGER FRONT TURN SIGNAL BULB AND ELCTRICAL UNIT MELTED. TURN SIGNAL ON DASH BLINKING FAST. CHANGED TO NEW BULB, THOUGHT BULB WAS BAD, REPLACED. WORKED FOR A FEW MONTHS AND IT OCCURRED BULB HAD BLOWN OUT. REPLACED AGAIN.. THIS TIME IT HAG GONE OUT AND EVERYTHINGS MELTED.. CONTACTED GM, HAVE A INCIDENT NUMBER. STATED THEY'LL SPEAK WITH DEALER SERVICE DEPARTMENT TO SEE IF THEYLL COVER A PORTION OF REPAIR. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT IMMEDIATELY AFTER STARTING, THE VEHICLE STALLED. THE CONTACT ALSO STATED THAT THE KEY BECAME STUCK CAUSING HIM TO BE UNABLE TO START THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,728.

WHILE ACCELERATING ONTO AN EXPRESSWAY THE WARNING CHIME SOUNDED, A CLICK WAS HEARD UNDER THE INSTRUMENT PANEL, AND THE (ELECTRIC) POWER STEERING ASSIST QUIT. ALSO A BATTERY SYMBOL ILLUMINATED MOMENTARILY ON THE INSTRUMENT PANEL. REDUCING ACCELERATION CAUSED THE POWER STEERING ASSIST TO RETURN TO NORMAL. UPON FURTHER TESTING IT WAS DETERMINED THAT THIS HAPPENS REPEATEDLY AT ANY SPEED WHEN UNDER HEAVY ACCELERATION (OFTEN AT ABOUT 4000 RPM) AND WHILE HILL CLIMBING UNDER LOAD AT ABOUT 2100 RPM. IT WAS NOTED THAT SIMULTANEOUSLY THE BATTERY VOLTAGE WENT EXCESSIVELY HIGH (16V, SOMETIMES 17V) AND OCCASIONALLY MULTIPLE (ALL?) INSTRUMENT PANEL WARNING LIGHTS ILLUMINATE. IF THE POWER STEERING ASSIST QUITS WHILE TURNING THE STEERING WHEEL TENDS TO JERK HARD TOWARDS GOING STRAIGHT, A DECIDED SAFETY ISSUE. THIS MAY BE THE SAME ISSUE DETAILED IN THE JUNE 2010 TECHNICAL SERVICE BULLETIN: TSB # 08-02-32-005A AND IT APPEARS TO NOT BE COVERED UNDER WARRANTY. *TR

I PURCHASED THIS VEHICLE USED AND HAVE HAD AN ELECTRICAL PROBLEM WITH THE PASSENGER HEADLIGHTS.GOING ON AND OFF.I HAVE REPLACED THE WIRE HARNESS 7 TIMES IN 2 YEARS.IS THEIR A RECALL ON THESE CARS FOR THE HEADLIGHT ISSUES.IF SO I NEED TO BE NOTIFIED ASAP BEFORE THEIR IS A FIRE IN MY CAR.I AM A HANDICAP MOTHER THAT NEEDS HER CAR. *TR

A 2005 CHEVROLET MALIBU MAXX LS. 156964 MILEAGE. THE STEERING WHEEL EMITTED A CLUCKING AND A CREAKING NOISE WHILE MAKING A TURN. A CLAPPING REPEATED NOISE SOMEWHERE IN THE WHEELS HAS APPEARED ALSO. BLINKERS BURNED OUT TOO OFTEN AND THE PLASTICS THAT COVER THEM ARE MELT DOWN. IF IT STAYS MORE THAN 10 MINUTES STOPPED AFTER DRIVING A WHILE, THE TEMPERATURE GAUGE START RISING TO THE OVERHEAT POINT, BUT IF YOU TURN ON THE AIR CONDITIONING IT COMES BACK TO THE MEDIUM READING MEASUREMENT GAUGE. *TR

WHEN STARTING THE CAR IT WOULD HESITATE BEFORE TURNING OVER. LATER IT BEGAN TO STRUGGLE TO TURN OVER. NOW ITS STRUGGLING TO TURN OVER BUT WON'T. I PURCHASED A NEW BATTERY AT FIRESTONE LESS THAN A MONTH AGO AND THE CAR HAS PLENTY OF GAS. I ALSO TOOK THE CAR INTO FIRESTONE FOR A VEHICLE INSPECTION THE DAY BEFORE I BOUGHT THE BATTERY. IF THE CAUSE IS A DEFECTIVE FUEL PUMP, THE PUMP MAY SEIZE STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION. A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE. MANY CHEVY MALIBU OWNERS FOUND THAT THE ALARM OR ANTI-THEFT SYSTEM HAD THE FUEL SYSTEM LOCKED AND THE CAR WOULD NOT START. THIS HAPPENS RANDOMLY AND AT THE MOST INCONVENIENT TIMES. THE OWNER'S MANUAL SAID TO TURN THE IGNITION KEY TO THE ON POSITION LEAVE IT ON FOR 10 MINUTES, THEN TURN...

I PURCHASED MY CHEVY MALIBU MAXX JANUARY OF JUST LAST YEAR AND I HAD TO REPLACE MY FRONT LEFT HEAD LIGHT THINKING NOTHING OF JUST NORMAL MAINTENANCE AND THIS WAS RIGHT AROUND AUGUST OF LAST YEAR AND IT IS NOW MARCH OF 2013 AND I JUST HAD TO DO IT AGAIN BUT THIS GO ROUND IT SEEMED MORE LIKE A SHORT BECAUSE IT STOPPED WORKING ONE NIGHT DRIVING HOME FROM WORK WHICH I DRIVE A VERY BUSY HIGHWAY AT NIGHT AND THAT NEXT MORNING IT WAS WORKING JUST FINE SO ME BEING THE NORMAL AMERICAN PERSON I THINK NOTHING OF IT BUT THE FOLLOWING DAY IT GOES OUT FULLY AND WHEN I WENT TO GO CHANGE THE LIGHT THIS TIME I NOTICED IT HAD ACTUALLY BURNED THROUGH THE AMBER COLOR COVER OF THE BULB AND ALSO BURNED THE SOCKET UP IN THE VEHICLE. BUT NOW GET THIS ABOUT THE SAME...

TURN SIGNALS BURNING SO HOT THEY EXPLODE, AND MELT NOT ONLY HOUSING FOR BULB, BUT ALSO THE SOCKET IN ORDER TO REPLACE BULB IS MELTED TOO. THERE NEEDS TO BE A RECALL ON THIS AS I HAVE FOUND OVER 200 OTHER COMPLAINTS OF PEOPLE HAVING THE SAME ISSUE! *TR

MY CARS HEADLIGHTS ARE DIM AT NIGHT AND TAKE A WHILE TO GET BRIGHTER EVEN THOUGH I HAVE HAD THE BULB REPLACED AND THE LIGHTING COMPONENTS CHECKED OUT. THE WINDOWS WON'T ROLL DOWN FROM ANY SIDE OF THE CAR, A RECURRENCE FROM TWO YEARS AGO. ALSO MY DOORS WON'T UNLOCK FROM THE AUTO-UNLOCK BUTTON THAT SITS ON THE DRIVERS SIDE, THIS HAS BEEN AN ISSUE FOR THE PAST 2 YEARS OF MY CHEVROLET CAR OWNERSHIP. *TR

I HAVE OWNED MY 2005 MALIBU MAXX FOR JUST OVER A YEAR AND HAVE HAD TO REPLACE THE FRONT TURN SIGNAL SOCKETS, BOTH DRIVER AND PASSENGER SIDES, THREE TIMES NOW DUE TO MELTED SOCKETS AND AMBER COVERS MELTING DOWN TO THE BULBS. EVEN THOUGH THEY ARE VENTED THEY DO NOT STAY COOL ENOUGH TO PREVENT SEVERE ELECTRICAL DAMAGE TO THE COMPONENTS. IN REPLACING THESE COMPONENTS I HAVE TO WAIT A WEEK UNTIL THE PARTS ARE SHIPPED OUT AND AM FORCED TO DRIVE WITH FAULTY EQUIPMENT. I AM UNABLE TO JUST REPLACE THE BULBS AND HAVE TO CONSTANTLY CHANGE THE BULBS OUT BEFORE THEY MELT TO THE SOCKETS. THIS IS A HUGE HAZARD AS THEY CAN GO OUT ON ME IN THE MIDDLE OF DRIVING IN RUSH HOUR TRAFFIC PUTTING ME AT A GREATER RISK OF INJURY. PLEASE FORCE GM TO ISSUE AN ACTUAL RECALL ON THIS ISSUE AND NOT JUST...

I HAVE A 2005 MALIBU MAXX. APPROXIMATELY 2 1/2 WEEKS AGO, I WAS PULLING INTO A PARKING SPACE -VERY, VERY SLOWLY, THERE WERE A SERIES OF RED POLE ABOUT 3 FEET HIGH, I SAW THEM. I WAS TURNING RIGHT AND MY CAR JERKED TO THE LEFT ACCELERATED AND I HIT A POLE DAMAGING MY FRONT END. CAR WAS TOWED AND REPAIRED BY STATE FARM INSURANCE FOR ABOUT $2500.00. I GOT MY CAR BACK AND DROVE IT FOR ABOUT TWO WEEKS, I WAS AGAIN PULLING INTO A PARKING SPACE ONLY I WAS COMPLETELY IN AND PARKED, I WAS BRAKING AND SHUTTING OFF MY CAR WHEN THIS HAPPENED. THE BRAKE WENT COMPLETELY LOOSE, THE STEERING WHEEL STARTED TO SPIN AND THE CAR SURGED, IT SURGED AND FLEW OVER THE CURB ABOUT 6 FEET INTO AN ICE MACHINE AT A SPEEDWAY GAS STATION ON 15 MILE AND DODGE PARK IN STERLING HEIGHTS. THIS...

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXI. THE CONTACT STATED THAT THE TURN SIGNALS OVER HEATED, WHICH CAUSED THE SOCKETS TO MELT. THE DEALER AND MANUFACTURER DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE 65,000 AND THE CURRENT MILEAGE WAS 140,000. THE VIN WAS UNAVAILABLE.

COMPLETE AND TOTAL LOCK UP OF POWER STEERING; BATTERY LIGHT FLICKS ON AND THEN EVERYTHING LOCKS UP UNTIL YOU REPLACE THE GAS PEDDLE FOR ABOUT 3 SECONDS. MY LIGHTS RANDOMLY FLASH AND REAR BULBS ON THE DRIVER SIDE BLOW EVERY 3 DAYS. MY TURN SIGNALS WILL SPORADICALLY BLINK AND THE WIPER BLADES GO OFF WITH OUT WARNING OR BEING PROMPTED. EVEN WITH NO KEYS NEAR OR IN THE CAR IT WILL NOT TURN OVER TO START THE CAR UNTIL YOU FLOOR THE GAS PEDDLE AND HOLD IT THERE FOR 3-5 SECONDS. MY RADIO READS AT -19* ALL THE TIME AND THE CD PLAYER HAS NEVER WORKED CORRECTLY. WHEN GOING FROM 0 TO 50 GETTING ON THE PARKWAY (HIGHWAY) THE WHOLE CAR LOCKS UP AND LOSES POWER INCLUDING THE STEERING RADIO AND LIGHTS UNLESS YOU COMPLETELY RELEASE THE GAS THEN START TO GO AGAIN. IM SO HIGHLY FRUSTRATED AND CHEVY REFUSES...

THE STEERING HAS A HEAVY CLUNK SOUND WHEN TURNING LEFT IN REVERSE, NO SOUND WHEN GOING TO THE RIGHT. THEN AT JUST OVER 50K MILES, THE STEERING ON THE VEHICLE STARTED HAVING ISSUES WITH POWER WHILE TURNING TO THE RIGHT UNDER POWER, TO THE LEFT WAS JUST FINE. THE HEAD LAMPS ALSO HAVE GOTTEN SEVERELY CLOUDY WHICH LIMITS VISIBILITY DURING NIGHT TIME DRIVING. FRONT TURN INDICATOR LIGHTS ALSO HAD A PROBLEM WITH LOOSE SOCKETS, CAUSING THE LIGHTS TO SHORT OUT AND EVENTUALLY FAIL BECAUSE OF SPARKING RESIDUE ON THE CONTACTS. ALSO, FOR SOME REASON THE REAR WINDOW WIPER RANDOMLY TURNS ON FOR NO APPARENT REASON. THE VEHICLE ALSO HAS A STARTING PROBLEM WHERE AT TIMES, THE VEHICLE WILL CRANK AND NOT START. LOOKING AROUND, QUITE A FEW FOLKS HAVE THAT PROBLEM AS WELL, WHERE SOME PEOPLE HAVE HAD TO SHORT OUT THE HOOD SAFETY SWITCH TO MAKE THE CAR WORK......

2005 MAILBU MAXX. CONSUMER STATES INTERMITTENT PROBLEMS WITH BRAKE LIGHTS *TGW THE CONSUMER STATED THE BRAKE LIGHTS WOULD ILLUMINATE WHEN THE BRAKE WASN'T APPLIED AND WOULD NOT ILLUMINATE WHEN THE BRAKE WAS APPLIED. THE DEALER REPLACED THE BRAKE LAMP, BUT THE PROBLEM CONTINUED. *JB

THE DRIVERS SIDE TURN SIGNAL (INSIDE THE HARNESS IN THE HEADLIGHT) KEEPS MELTING THE PLASTIC SNAP IN BASE OF THE TURN SIGNAL LIGHT BULB AND CAUSES IT TO BECOME INOPERATIVE. ALMOST CAUSING OTHER VEHICLES TO CRASH IN TO ME AT 4 WAY STOP SIGNS. THE HARNESS ASSEMBLY GETS VERY HOT. MAY ONE DAY CAUSE A FIRE. I HAVE REPLACED LIGHT BULBS 4 TIMES IN THE LAST MONTH. WILL HAVE TO GET SERVICED. *TR

ELECTRICAL ISSUES WITH MY 05 MALIBU MAXX.THE POWER STEERING KEEPS GOING OUT-CHEVY IS AWARE OF THIS PROBLEM. THE ENGINE HAS TROUBLE STARTING. THE REAR WIPER GOES BY ITSELF WITHOUT ANYONE TOUCHING THE CONTROL-MOST RECENT EVENT, HAPPENS EVERY FEW DAYS 1 OR 2 TIMES. I HAVE HAD ISSUES WITH THE STARTING FROM THE BEGINNING OF OWNERSHIP. THE POWER STEERING ISSUE HAS BEEN OVER THE PAST MONTH. SOMETIMES THE WARNING LIGHT COMES ON FIRST, USUALLY NOT. I HAVE NOT PAID TO HAVE ANY WORK DONE, BUT HAVE CONTACTED CHEVY'S CUSTOMER SERVICE AND WAS TOLD, THAT THEY WOULD MAKE A RECORD OF IT. RESTARTING THE CAR USUALLY FIXES THE POWER STEERING TEMPORARILY. I HAVE TO CHANGE THE BRAKES ONCE A MONTH, SO THEY DON'T DESTROY MY ROTORS. POWER STEERING SEEMS TO GO OUT MORE OFTEN WHEN IT IS HOT OUTSIDE. *TR

BRAKE LIGHTS COME ON BY THEMSELVES AND GO OUT WHEN PEDAL IS PUSHED. TRIED NEW SWITCH, CALIBRATION, AND TSB PROCEDURE. PROBLEM WILL GO AWAY FOR A MONTH OR TWO THEN RETURN. HAS BEEN HAPPENING FOR THE LAST 2 YEARS. NUMEROUS COMPLAINTS ON THE WEB. I HAVE SEEN OTHER CARS DRIVE BY WITH THE SAME PROBLEM. MAY WORK FINE IN THE MORNING THEN ACT UP IN THE EVENING. ALSO IMPACTS THE SIFT INTERLOCK AND CRUISE CONTROL. THE OTHER DAY THE CRUISE CONTROL WOULD NOT DISENGAGE WHEN I APPLIED THE BRAKES. I HAD TO TURN IT OFF BY THE SWITCH ON THE STEERING WHEEL. *TR

2005 CHEVROLET MALIBU MAXX (1) FRONT PARK/TURN/DRL LAMP INOPERATIVE AND OVERHEATING PROBLEMS. (2) REAR STOP/TURN/TAIL LAMP INOPERATIVE PROBLEMS. THIS CAR CURRENTLY HAS 41,000 MILES. THE LAMPS FOR THE LEFT FRONT (DRIVER SIDE)HAS BEEN REPLACED 5 TIMES AND RIGHT FRONT 3 TIMES. THE REAR LAMPS HAS BEEN REPLACED 3 TIMES EACH SIDE. MY MAJOR CONCERN AND CAUSE FOR THIS COMPLAINT IS THE OVERHEATING OF THE FRONT LAMPS (ITEM #1 ABOVE). THE UPPER SIDE AMBER PLASTIC HOUSING FOR THE LAMPS ON BOTH RIGHT AND LEFT HAS MELTED THROUGH AT THIS TIME. WHEN THE PROBLEM WAS FIRST DETECTED, THE AMBER HOUSING SHOWED SOME DISCOLORATION, BUBBLED PLASTIC. THIS SUGGESTED THE OVERHEATING PROBLEM EITHER HAS INTENSIFIED AND/OR THE PLASTIC HAS DEGRADATED OVER TIME. VISUAL INSPECTION SHOWED THE CHARRED/BURNT THROUGH AREAS ARE ADJACENT TO THE LAMP SOCKET. THIS INDICATES EXTREME SOCKET TEMPERATURE AND ALSO THE RISING HOT AIR AFFECT THE CEILING OF THE AMBER HOUSING. ALL...

2005 MALIBU MAXX, STARTER ASSEMBLY: SOMETIMES DIFFICULT TO START, ESPECIALLY AFTER RUNNING THE AIR CONDITIONER.PROBLEM STARTED ABOUT 3 YEARS AGO, OCCURRED SINCE THEN ABOUT 40 TO 50 TIMES. I RETIRED 18 MONTHS AGO AND DO NOT DRIVE AS MUCH NOW THAN I DI WHILE WORKING. THE PROBLEM PERSISTS DESPITE NEW BATTERY AND NOT RUNNING CONCURRENTLY THE FOLLOWING:AIR CONDITIONER DISK PLAYER, WINDSHIELD WIPERS,LIGHTS. ALL THE SYSTEMS ALWAYS CHECKED OUT OK, NO PROBLEM WAS DETECTED. *TR

I HAVE HAD NUMEROUS PROBLEMS WITH THE STARTER TURNING OVER EVEN WHEN THE CAR STARTS AND SOMETIMES IT STILL WONT START. THE DEALER SAYS IT NORMAL AND AFTER IT GETS MILES ON IT THEN IT WILL STOP... IT NOW HAS 52,000 MILES ON IT AND STILL DOES IT. I ALSO HAVE HAD TO HAVE IT IN THE SHOP EVERY COUPLE OF MONTHS TO HAVE IT LUBED IN THE FRONT AXLE WHICH I HAVE TALKED TO OTHER MECHANICS AND THEY STATED THAT IT SHOULD NOT BE NEEDING IT EVER FEW MONTHS, IF I DON'T DO IT THEN EVERYTIME I TURN LEFT OR RIGHT THERE IS THIS HORRIBLE POPPING SOUND FROM THE FRONT END. I ALSO AM HAVING WIRING TROUBLE WITH THE CAR, THE FRONT BLINKER WONT WORK NO MATTER HOW MANY LIGHT BULBS I PUT IN IT, IT WONT WORK AND EVEN KEEPS MELTING THE PLASTIC ON THE BULB ITSELF. *TR

TURN SIGNAL & 4-WAY FLASHER OPERATION, COMPLETE FAILURE, INTERMITTENT. HOT, COLD, KEY/ENGINE/HEADLAMPS ON/OFF. DRL REMAINS FUNCTIONAL. *TR