1997 CHEVROLET CAVALIER Electrical Systemignitionswitch Problems

THE IGNITION SYSTEM. *TR

MY CAR HAS RECENTLY CAUGHT FIRE. THE FIRE STARTED IN THE STEERING COLUMN. MY CAR WAS A TOTAL LOSS. *JB

DT RECALL 00V053000 WAS ISSUED CONCERNING THE FUEL SYSTEM. THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. GASOLINE WAS LEAKING FROM THE RETURN AND THE FEED LINE. THE RETURN LINE STARTED LEAKING FIRST AND THEN A MONTH LATER, THE FEED LINE STARTED LEAKING. NOTICED IT ON JULY 29, 2005 THIS IS WHEN THE RETURN METAL FITTING WAS LEAKING AND THE RETURN STARTED LEAKING ON AUGUST 29, 2005. CONTACTED THE DEALER, THE PART THAT HAS TO BE REPLACED, INCLUDING THE WHOLE UNIT, AND WITH LABOR WOULD COST $600.00 OR $700.00. ALSO, IGNITION SWITCH RECALL 02V070000. THIS VEHICLE FAILED TO START. THE VEHICLE WOULD NOT TURN OVER IT COMPLETELY. THE DASH WARNING LIGHTS WOULD COME ON. THE DEALER HAS NOT LOOKED AT ANY OF THESE PROBLEMS. THERE WAS ALSO A RECALL 98V146000 CONCERNING AIR BAGS. VEHICLE'S AIR BAG LIGHT WAS ON. DID NOT HAVE THE DEALER CHECK THIS. *AK *JB

CONSUMER ATTEMPTED TO START VEHICLE BUT IT FAILED TO DO SO. CONSUMER LIFTED UP THE HOOD AND NOTICED THAT MAIN WIRE TO STARTER CAUGHT ON FIRE. THE DRIVER WAS ABLE EXTINGUISH THE FIRE. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC REPLACED THE IGNITION SWITCH DUE TO A WORN OUT RELAY SWITCH. *AK

WHEN ATTEMPTING TO START VEHICLE IGNITION SWITCH STUCK. RECALL 02V070000 REPAIRS WERE PERFORMED, BUT PROBLEM STILL RECURRED. ALSO, WHILE DRIVING THE BEARING HUB PRODUCED A GRINDING NOISE ON THE LEFT SIDE. THE CAUSE HAS YET TO BE DETERMINED BY THE MECHANIC. *AK

MY IGNITION SWITCH RECALL IS A PROBLEM AND THE RECALL NOTICE SAYS THAT THE INTERNAL PARTS OS THE SWITCH WILL MELT IF HELD TOO LONG IN THE START POSITION AND I HAVE HAD A PROBLEM WITH MY SWITCH. I TOOK IT OFF AND APART AND FOUND THAT THE INTERNAL PARTS WERE MELTED AS IT SAYS IN THE NOTICE. MY NOTICE SAYS THAT THEY WERE TO TEST AND REPLACE THE SWITCH IF NECESSARY AS WELL AS PUT THE ADDITION TO THE CIRCUIT AND I DID NOT GET A NEW SWITCH PLEASE ADVISE AS WHAT TO DO. ALL I WOULD LIKE IS MY SWITCH REPLACED. I CALLED THE CHEVROLET 800 CUSTOMER SERVICE NUMBER AND I DID NOT RECEIVE ANY HELP. THANK YOU TED L HOWARD 714-630-3844 *PH

ON APRIL 23, 2003 VEHICLE WAS TAKEN TO THE DEALER FOR TWO RECALLS. THE FIRST WAS RECALL 02V070000 CONCERNING IGNITION SWITCH. THE SECOND WAS RECALL 02V286000 CONCERNING POWER STEERING ASSEMBLY. AFTER RECALL REPAIRS WERE DONE, THE VEHICLE WOULDN'T START INTERMITTENTLY. VEHICLE WAS TAKEN TO THE DEALER THREE TIMES, DEALER DID DIAGNOSTIC TESTING AND COULD NOT DETERMINE THE CAUSE OF PROBLEM. THE VEHICLE DID NOT HAVE THESE PROBLEMS BEFORE THE RECALL REPAIRS. *AK

NHTSA#02-V-070-000 THE RECALL WHICH WAS PERFORMED ON THE VEHICLE REGARDING THE IGNITION SWITCH FAILED. *JB

THE CONSUMER RECEIVED A RECALL NOTICE 02V07) REGARDING A POSSIBLE FIRE IN THE STEERING COLUMN. THE DEALER STATED THAT PARTS WOULD NOT BE AVAILABLE UNTIL MAY 2002. *YH

PRIOR TO RECALL NOTIFICATION, (02V070000) CONSUMER WAS HAVING TROUBLE WITH THE VEHICLE STARTING, THE DEALER WAS UNABLE TO DIAGNOSIS THE PROBLEM, AFTER RECEIVING RECALL NOTICE, CONSUMER TOOK VEHICLE TO THE DEALER AND HAD THE WORK PERFORMED AND STATED THAT ALL THE WORK THAT WAS PERFORMED PREVIOUSLY WAS RECALL RELATED, CONSUMER WAS INFORMED THAT A CLAIM WOULD BE SUBMITTED FOR REIMBURSEMENT, HOWEVER CONSUMER HAS WAITED FOR 60 DAYS AND HAS NOT HEARD FROM MANUFACTURER.*JB

CONSUMER STATES VEHICLE FAILS TO START. CONSUMER IS AWARE OF RECALL 02V070000 RELATING TO NO START CONDITION. HOWEVER, DEALER CANNOT PERFORM RECALL REPAIRS DUE TO LACK OF PARTS. CONSUMER IS CONCERNED THAT VEHICLE MAY CATCH FIRE. *TT

DEALERSHIP CHARGE FOR RECALL 02V070000 REPAIRS AFTER WORK WAS DONE. *AK

WHILE WAITING FOR RECALL 02070000 REPAIRS APPOINTMENT DATE IGNITION SWITCH CAUGHT ON FIRE AND DAMAGED OTHER COMPONENTS. CONSUMER WAS CHARGED.*AK

CONSUMER STATES ONE WEEK PRIOR TO RECEIVING RECALL 02V07, THE IGNITION SWITCH FAILED AND IT WAS REPLACED, CONSUMER IS BEING DENIED REIMBURSEMENT DUE TO HAVING THE PART REPLACED BEFORE THE RECALL WAS EFFECTIVE. *SLC

AFTER RELAY SWITCH WAS INSTALLED FOR RECALL O2V070000 STARTED HAVING LOTS OF PROBLEMS WITH VEHICLE, SUCH AS BATTERY FAILURE, ETC.DEALER CONTACTED.*AK

VEHICLE CAUGHT ON FIRE DUE TO IGNITION SWITCH FAILURE. STEERING WHEEL/DASHBOARD CAUGHT ON FIRE . CONTACTED DEALER ,AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK

SINCE RECALL 02V070000 REPAIRS ON IGNITION SWITCH WERE DONE VEHICLE WOULD NOT START INTERMITTENTLY. DEALER HAS REPAIREDVEHICLE A SECOND TIME, AND CHARGED THE CONSUMER FOR THE WORK.PLEASE PROVIDE FURTHER INFORMATION. *AK

PARTS RECALL 02V070000 HAVE NOT BEEN AVAILABLE FOR 2 MONTHS, AND CONSUMER WAS SUPPOSE TO BE NOTIFIED OF PARTS DELIVERY,BUT DEALERSHIP NEVER CALLED.*AK

CONSUMER WAS TOLD THAT PARTS FOR RECALL O2V070000 CONCERNING IGNITION SWITCH FAILURE WOULD NOT BE AVAILABLE UNTIL JUNE, ALMOST THE END OF JUNE AND NOT PARTS AVAILABLE YET.*AK

VEHICLE FIRE WAS CAUSED BY A SHORT IN IGNITION SWITCH. *AK

CONSUMER STATES WHEN THE VEHICLE WAS STARTED AND TURNED OFF BY THE IGNITION VEHICLE KEPT RUNNING. THE DEALER WILL INSPECT THE VEHICLE. THE VEHICLE IS INCLUDED UNDER THE RECALL 02V070000. NLM

WHILE ATTENDANT WAS SERVICING VEHICLE HE PLACED KEY INSIDE OF IGNITION, AND VEHICLE WOULDN'T TURN OVER. IGNITION SWITCH STARTED SMOKING , AND VEHICLE CAUGHT ON FIRE. *AK

KEY WAS PLACE INSIDE OF IGNITION AND VEHICLE WOULDN'T TURN ON. DEALERSHIP WA SAWARE OF PROBLEM.*AK

WHILE BACKING UP CONSUMER NOTICED SMOKE COMING FROM IGNITION SWITCH. THEN, FLAMES. HE SHUT OFF ENGINE, AND FIRE WENT OUT. CONSUMER CALLED CHEVROLET CUSTOMER SERVICE ABOUT THE RECALL ON IGNITION, IT HAS NOT BEEN DETERMINED IF THIS VEHICLE WAS AFFECTED BY RECALL. *AK

I GOT THE LETTER ABOUT THE RECALL OF THE IGNITION STARTER SWITCH THAT MIGHT CAUSE A FIRE. ON SATURDAY, THAT IS EXACTLY WHAT HAPPENED. I HAD THE CAR REPAIRED, BUT DIDN'T KNOW UNTIL MONDAY WHEN I GOT THE LETTER FROM GM. I AM VERY UPSET THAT THEY TOLD ME TO WAIT UNTIL JULY FOR THEM TO GET THE REPAIR KIT. IN OTHER WORDS... I HAVE TO DRIVE AROUND FOR 3 MONTHS WORRYING ABOUT MY SAFETY AND WHERE I MIGHT BREAK DOWN. MY WIFE AND I WERE PLANNING ON DRIVING TO FLORIDA FOR 2 WEEKS AND NOW I MIGHT HAVE TO CANCELL. I THINK THEY SHOULD COMPENSATE ME WITH A RENTED CAR UNTIL THEY FIX MINE. IT'S LIKE TELLING ME THAT I HAVE AN OVEN THAT MIGHT GO ON FIRE IF I USE IT FOR THE NEXT 3 MONTHS. I WOULDN'T USE THE OVEN SO WHY WOULD I USE MY CAR....

WHILE PLACING KEY INSIDE OF THE IGNITION VEHICLE WILL NOT TURN ON AT ALL. *AK

IGNITION SWITCH FAILURE. *AK

ON THURSDAY, MAY 31, 2001, THE VEHICLE AILED TO START AND WAS JUMP STARTED. WE THEN DROVE HOME (5 MINS' DRIVE AWAY) AND PARKED THE VEHCLE IN OUR CARPORT. ABOUT 5 MINS LATER A NEIGHBOR CAME TO TELL US THAT THE VEHICLE WAS ON FIRE. THE FIRE ORIGINATED IN THE STEERING WHEEL COLUMN (PROBABLY DUE TO A PROBLEM WITH THE IGNITION) AND DESTROYED THE IGNITION, WIPER SWITCH, TURN SIGNAL SWITCH AND THE COVERS. ADDITIONAL DAMAGE WAS DONE WHILE TRYING TO PUT OUT THE FIRE. THE FIRE BRIGADE WAS CALLED TO THE SCENE. THE INCIDENT COULD HAVE BEEN MUCH MORE SERIOUS IF THE FIRE HAD NOT BEEN SPOTTED SO QUICKLY. *AK

IGNITION SWITCH FAILED. NLM

WHILE DRIVING THE VEHICLE BUCKS AT ONE POINT AS IF IT LACKS GAS AND IT ALSO STALLS. DEALER HAS BEEN CONTACTED. *AK CONSUMER RECIEVED RECALL TO REPLACED PCM. PCM REPLACED 4 TIMES HOWEVER PROBLEM STILL EXIST. CONSUMER RECEIVED RECALL TO REPLACE THE IGNITION SWITCH. *TT

FRONT BRAKE PADS/ROTOR WORE OUT, CAUSING VIBRATION WHEN BRAKES ARE APPLIED. ALSO DEALER REPLACED ENGINE MOUNTS/IGNITION SWITCH. BRAKE LINE WAS FOUND RUBBING AGAINST AXLE SHAFT AND WAS FIXED. IN ADDITION, FRONT END SHAKES/VIBRATES.

DEFECT WITHIN IGNITION SYSTEM IS CAUSING VEHICLE TO BECOME INOPERATIVE , ENGINE WILL NOT START. DEALER HAS REPLACED IGNITION SWITCH 4 TIMES, DEFECT IS STILL OCCURRING. *AK