2003 BUICK CENTURY Structure Problems

ONGOING LEAKS AT BOTTOM OF BOTH REAR DOORS FOR SOME YEARS DESPITE AT LEAST 3 ATTEMPTS BY DEALER TO FIX. I FINALLY RESOLVED ON MY OWN WITH PLASTIC SHEETING WHICH IS UNSIGHTLY. ALSO DISCOVERED LEAK IN TRUCK IN PAST YEAR. ANOTHER ISSUE IS POOR QUALITY OF THE 2 CONTROL KNOBS ON DASH BOARD FOR A/C, ETC. THEY HAVE EITHER BROKEN OR HAVE BEEN DIFFICULT TO TURN. *TR

THE CROSS MEMBER HOLDING THE ENGINE CAME LOOSE AND DROPPED THE ENGINE TO ABOUT 6 INCHES FROM THE GROUND. ONLY 1 BOLT WAS FOUND. THIS WAS DISCOVERED WHILE BACKING OUT OF THE DRIVEWAY. IT WILL REQUIRE A FLOOR JACK TO LIFT THE ENGINE SO THE BOLT CAN BE REPLACED AND THEN TOWED TO A SHOP FOR INSPECTION OF FURTHER POSSIBLE DAMAGE. *TR

MY 2003 BUICK CENTURY'S WINDSHIELD LOWER SEAL FAILED AROUND THE CABIN-FILTER AREA AND ALLOWED WATER TO RUN DOWN THE FIREWALL AND INTO MY CAR UNDER MY CARPETING AND POOL ON THE FLOOR. THIS CORRODED THE WIRES LEADING TO MY POWER DRIVER'S SEAT. THESE WIRES ALSO LEAD TO A DEVICE THAT CONTROLS THE AIRBAGS (A SENSOR?). GM TOOK MY SEATS, CONSOLE AND CARPETING OUT TO FIX THE WIRING. HAD THE AIRBAG NEEDED TO DEPLOY, I DOUBT IT WOULD HAVE GIVEN THE CONDITION OF THE WIRING, AND/OR IT CERTAINLY WOULD MOST LIKELY CORRODE THAT SENSOR SOONER OR LATER, RENDERING IT AND THEREFORE THE AIRBAG, USELESS. THE GM MECHANIC SAID THAT,"THIS HAS BEEN A DESIGN FLAW BY GM FOR MANY YEARS WITH THE BUICK CENTURY" -- I THINK HE MENTIONED 2002 TO 2004 MODELS. HE SAID HE'S SEEN THIS MANY TIMES. THE MANAGER AT THE BUICK DEALER SAID THAT HE TOLD THE GM...

CONSUMER COMPLAINED ABOUT DOORS LOCKING AND UNLOCKING WHILE DRIVING. THE DEALER INSPECTED THE VEHICLE SEVERAL TIMES BUT COULD NOT DUPLICATE OR CORRECT THE PROBLEMS. THE DASHBOARD WAS ALSO FALLING APART. *AK *NM THE TRUNK POPPED OPEN, THE BRAKES WERE INOPEATIVE, THERE WAS A FUME SMELL COMING FROM THE VEHICLE. UPDATED 12/13/05. *JB

THE WAY THE DASHBOARD IS DESIGNED IT GIVES OFF A REFLECTION OF ITSELF ONTO THE WINDSHIELD. THE REFLECTION IS MORE APPARENT IN THE SUNLIGHT. THIS RESULTS IN POOR VISIBILITY. MANUFACTURER SUGGESTED THAT CONSUMER COVER THE DASHBOARD. BUT, ACCORDING TO OWNER'S MANUAL, SENSORS ON THE DASHBOARD SHOULD NOT BE COVERED. THE CORRECT MODEL YEAR IS 2004, NOT IN ARTEMIS. *AK