2008 BMW 535XI Fuelpropulsion System Problems

MY BMW IS A 2008 BMW 535XI THAT WAS MANUFACTURED ON 02/2008. I HAVE HAD AN ISSUE WITH CYLINDER 4 MISFIRING SO I CHANGED ALL 6 SPARK PLUGS AND CYLINDER 4 IGNITION COIL ONLY TO HAVE CYLINDER MISFIRING STILL. I TOOK IT TO A MECHANIC AND THEY CHECKED AND STATED THAT I HAD A BAD IGNITION COIL BECAUSE MY SPARK PLUG AND IGNITION COIL SMELLED LIKE FUEL. MY FRIEND IS A TECH AT A LOCAL BMW DEALERSHIP AND TOLD ME NOT TO REPAIR IT YET BECAUSE BMW HAS ISSUED A RECALL FOR MY VEHICLE WHICH IS A E61 SPORTS WAGON. I WILL PROVIDE THE DOCUMENT THAT SHOWS THAT MY VEHICLE IS UNDER THE AFFECTED VEHICLES. WHEN AT IDLE MY CAR SHAKES. THIS HAS BEEN GOING ON FOR ABOUT A YEAR I JUST NEVER HAD THE MONEY TO FIX IT AND DIDN'T KNOW WHAT THE ISSUES WERE UNTIL NOW. I DON'T...

TL* THE CONTACT OWNS A 2008 BMW 535XI. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE MISFIRED THE VEHICLE WAS TAKEN TO THE LOCAL DEALER BMW OF COLUMBIA LOCATED AT (1900 I70 DR. SW, COLUMBIA MO) WHO DIAGNOSED THAT THE ENGINE CYLINDER NUMBER 4 MISFIRE WAS DUE TO DEFECTIVE FUEL INJECTORS. THE FUEL INJECTORS WERE REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,450.

VEHICLE STALLS, HESITATES WHEN DRIVING. MESSAGE ON THE DASH SAYS THAT THE FUEL PUMP IS FAILING, BUT CAN BE DRIVEN WITH DECREASED PERFORMANCE AND TO BRING THE VEHICLE TO BMW. BROUGHT THE CAR TO BMW SERVICE AND THEY TOLD ME THAT THERE WAS A RECALL ON THE FUEL PUMP BUT MY CAR IS NOT COVERED BECAUSE I HAVE 159K MILES ONE THE SAID VEHICLE. UPON FURTHER INVESTIGATION WITH THE SERVICE ADVISOR, (CARLOS - NORWALK BMW), WHO IS POLITE AND HELPFUL, WE FOUND THAT THE CAR HAD ALREADY BEEN SERVICED FOR THREE SAME PROBLEM AT LEAST 3 TIMES. FIRST IS IN 2009 WHEN THEY REPLACED THE HIGH PRESSURE FUEL PUMP. AFTER FOLLOA YEAR 2010, THE SAME PROBLEM OCCURRED. THE DEALERSHIP AGAIN REPLACED THE SAME FUEL PUMP. THEN ON 2013, HAVING THE SAME PROBLEM AGAIN, THE DEALERSHIP REPLACED THE INJECTORS BUT THE PROBLEM IS STILL OCCURRING. THE PROBLEM HAD BEEN ONGOING AND...

WHILE DRIVING ON THE HIGHWAY AND LOCAL STREETS THE CAR SUDDENLY LOSES POWER AND CUTS OFF GIVING A FUEL PUMP MALFUNCTION. I HAD THE HIGH PRESSURE FUEL PUMP REPLACED AND THE PROBLEM STILL EXISTS. THIS HAS PUT MY WHOLE FAMILY IN DANGER BECAUSE IT HAS HAPPENED ON THE HIGHWAY AT SPEEDS IN EXCESS OF 50 MPH. THE CAR JUST SUDDENLY SHUT DOWN.

MECHANICAL INSPECTION REVEALED A CRACK IN INTAKE MANIFOLD. THIS DEFECT MANIFESTS ITSELF WITH DIFFICULTY STARTING THE ENGINE DURING COLD STARTS,HESITATION WHEN APPLYING THE GAS PEDAL FOR RAPID ACCELERATION ON HIGHWAY ROADS. THERE IS ALSO A ROUGH IDLE

ON THURSDAY MARCH 30TH I DROPPED THE CAR OFF WITH BRINSFIELD AUTO IN GREENSBORO, NC BECAUSE MY CHECK ENGINE LIGHT CAME ON. ON APRIL 6TH I PICKED IT UP WITH COMPLETED REPAIRS OF A CLEANED #5 FUEL INJECTOR THAT WAS DIAGNOSED AS RUNNING RICH BUT AFTER BEING CLEANED WAS RUNNING CORRECTLY AND CHECK ENGINE LIGHT WAS NO LONGER AN INDICATOR. ON APRIL 8TH I WAS DRIVING IN GASTONIA, NC AND THE CAR BEGAN SMOKING AND SHUDDERING TO THE POINT IT WAS NOT DRIVABLE. I PULLED INTO A CAR DEALERSHIP THAT WAS CLOSED BECAUSE IT WAS AFTER HOURS AND PARKED THE CAR. MY SON AND I GOT OUT OF THE CAR AND NOTICED A VERY CLEAR ODOR OF GAS. THERE WAS A COUPLE DRIVING THROUGH THE DEALERSHIP LOT WHO STOPPED AND ALSO NOTICED THE ODOR AND AGREED IT WAS INDEED FUEL AND I SHOULD NOT DRIVE THE CAR. IT WAS TOWED...

TL* THE CONTACT OWNS A 2008 BMW 535XI. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER AND OVERHEATED. IN ADDITION "PLEASE SHUT ENGINE OFF DUE TO OVERHEATING " WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

THE CAR HAS AN PASSENGER RESTRAINT ERROR THAT DOES NOT GO AWAY. THE CAR FUEL GAGE DOES NOT WORK EITHER

I RECENTLY PURCHASED A 2008 BMW 535XI AND HAVE HAD IT FOR ABOUT A WEEK OR SO. IT HAS SPENT MORE TIME IN THE SHOP THAN ON THE ROAD DUE TO FUEL INJECTORS CAUSING MISFIRES AND NOW THE HIGH PRESSURE FUEL PUMP HAS GONE OUT. I RECENTLY FOUND OUT ALSO THAT THIS IS A COMMON ISSUE WITH BMW AND THEY ARE PRETENDING THAT THE FUEL PUMP MALFUNCTION IN 3 & 5 SERIES ISN'T THEIR FAULT. I CHECKED THE CARFAX ON THE VEHICLE BEFORE BUYING IT AND IT WAS SERVICED REGULARLY AT A BMW DEALERSHIP. AFTER FURTHER RESEARCH I ALSO HAVE FOUND OUT THAT THE DEALERSHIP TOTALLY IGNORED THE RECALLS AND SCREWED OVER THE FIRST OWNER. BMW NEEDS TO TAKE FULL RESPONSIBILITY FOR SELLING CARS WITH KNOWN DEFECTIVE PARTS. I HAVE TO DROP $3800 TO FIX THE PROBLEMS THAT THE FUEL PUMP HAS CAUSED. THE CAR WON'T EVEN START NOW.

I WAS EXITING THE THE FREEWAY AND WHEN I WAS ON A BANKED ONRAMP THE ENGINE STOPPED RUNNING WHILE VEHICLE WAS IN MOTION. I LOST POWER STEERING AND THE ABILITY TO RELEASE THE BRAKE. I NEARLY LOST CONTROL OF THE VEHICLE AS THE UNEXPECTED LOSS IN POWER STEERING CAUSED ME TO LOOSE GRIP ON THE WHEEL. THE ENGINE WAS IN NEUTRAL WHEN THE ENGINE STALLED. UPON RESTARTING THE ENGINE (WHICH STRUGGLED TO START) THE "SERVICE ENGINE SOON TELLTALE" ILLUMINATED AND THE VEHICLE ENTERED "REDUCE ENGINE POWER MODE". AFTER SCANNING THE DTC (P3090) I LEARNED THE VEHICLE'S HIGH PRESSURE FUEL PUMP FAILED. I NOTICED BMW HAS A RECALL ON THE ISSUE. UNFORTUNATELY THEIR RECALL ONLY COVERS THE FUEL PUMP TO 120,000 MILES AND MY VEHICLE HAS ROUGHLY 9,500 MILES ABOVE THE COVERED THRESHOLD. BASED ON MY EXPERIENCE AND READING ONLINE I FEEL THE PUMP HAS SOME SORT OF DESIGN FLAW THAT...

I STARTED MY CAR AND UPON STARTING IT BEGAN RATTLING AND SHAKING VIOLENTLY. I TOOK A VIDEO OF THE MESSAGE THAT APPEARED ON THE DASH SAYING. ENGINE MALFUNCTION REDUCED POWER. *TR

TL* THE CONTACT OWNS A 2008 BMW 535XI. THE CONTACT STATED THAT THE VEHICLE VIBRATED UPON START UP. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TWO FUEL INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN THE NEW DESIGN FUEL INJECTORS MANUFACTURER'S RECALL. THE FAILURE MILEAGE WAS 145,000.

THE CAR WAS SHUDDERING DUE TO MISFIRING FUEL INJECTORS AND HAD ERRATIC ENGINE OPERATION. NOTE: BMW IS AWARE OF THIS PROBLEM AND ISSUED A VOLUNTARY RECALL IN DECEMBER 2010. BMW NOTED IN THE RECALL THAT THIS REPAIR IS TO BE COVERED UNDER WARRANTY REGARDLESS OF TIME OR MILEAGE ON THE VEHICLE. IN MY EXPERIENCE, BMW IS NOT HONORING THE VOLUNTARY RECALL NOTICE. *JS