2009 BMW 535I Fuelpropulsion System Problems

The car stop running completly when I was wainting at the stop light An anounsmemt came out in my dash saying that I have to repleaced the fuel pump I know that there was a recall abuot this problem but I never got any notice or letter from bmw

VEHICLE WAS OPERATING ON PUBLIC HIGHWAY AT 40 MPH IN FORWARD GEAR. ELECTRONIC FUEL PUMP STOPPED CAUSING IMMEDIATE ENGINE POWER FAILURE AND LOSS OF FORWARD MOVEMENT CONTROL. IT WAS SNOWING AND THERE WAS NO SHOULDER. NO SAFE LANE OR OTHER AREA TO COAST IMMEDIATELY INOPERABLE VEHICLE INTO. HEAVY TRAFFIC REPEATEDLY NEARLY COLLIDED. NO WAY TO SECURE IMMEDIATE SAFE REMOVAL OF INOPERABLE VEHICLE OFF ROADWAY. EMERGENCY FLASHERS QUIT AFTER 30 MINUTES. WRECKER TOO 2.5 HOURS TO ARRIVE, WHILE DRIVE WAS FORCED TO CHOOSE BETWEEN UNSHELTERED FREEZING SNOW AND ICE, AND REMAINING IN VULNERABLE VEHICLE FOR TOW TRUCK TO ARRIVE. VEHICLE DISPLAYED "FUEL PUMP FAILURE" ON DIAGNOSTIC LCD SCREEN IN VEHICLE. THREE HOURS LATER, VEHICLE STARTED UP AND RAN WITHOUT INCIDENT, AFTER SITTING. PROBLEM HAS OCCURRED THREE TIMES OVER THE PAST FIFE YEARS, AND OCCURS WITHOUT WARNING WHILE ENGINE IS RUNNING.

AT LEAST ONCE OR TWICE A WEEK MY VEHICLE ALL OF A SUDDEN LOSE POWER THE ENGINE MALFUNCTION LIGHT COME DASH. THEN ON THE IDRIVE SYSTEM IT ALWAYS SAY "FUEL PUMP" PROBLEM. THIS PROBLEM OCCURS UNEXPECTED AND HAS PUT ME IN DANGEROUS SITUATION ON THE HIGHWAY. I PULL OVER TO THE SHOULDER AND PUT THE FLASHERS ON. AFTER ABOUT TEN MINUTES THE FLASHERS GO OFF AND THE CAR IS ABLE TO DRIVE AGAIN. LASTLY, THE PROBLEM ALWAYS HAPPEN UNEXPECTED REGARDLESS ON CITY STREET OR HIGHWAY. I CAN BE TRAVELING AT 25 TO 75MPH AND IT JUST RANDOMLY HAPPENS. MANY OCCASIONS I DO NOT FEEL COMFORTABLE TRAVELING IN THE FAR LEFT LANE. DUE TO MOVING TO THE LEFT SHOULDER AND CARS TRAVELING AT A HIGHER RATE OF SPEED.

FUEL PUMP FAILURES, CAR SHUT DOWN WHILE DRIVING ON THE HIGHWAY (NUMEROUS TIMES) LOST POWER STEERING WHILE GOING OVER 60 MPH. COST OVER $10,000 TO MAKE REPAIRS ON THE VEHICLE BECAUSE BMW SAID IT IS NO LONGER UNDER WARRANTY.

THE CAR SHUTS OFF UNEXPECTEDLY WHEN IT'S BEING USED BECAUSE OF THE FUEL PUMP. I THINK IT'S UNFAIR THAT THE 2008 MODELS GOT RECALLS UP TO 10 YRS AND 120,000 MILES. I FEEL LIKE THE 2009 BMW XI WAS MISSING FROM THIS RECALL. THE SAME HIGH PRESSURE FUEL PUMP WAS THE PROBLEM FOR THE RECALL. I'M BOTH CLOSE TO REACHING MY 120,000 MILES OR THE 10 YR MARK SO IT WOULD BE AMAZING TO SEE SOMETHING BEING DONE ABOUT THIS SOON.

FUEL PUMP ERROR WHILE DRIVING AND THE CAR SHUTS DOWN, WE LOSE POWER STEERING AND HAVE DONE SO ON THE HIGHWAY, AND CITY NUMEROUS TIMES.

STOPPED IN TRAFFIC AT A RED LIGHT AFTER APPROXIMATELY 15 MINUTES OF DRIVING. THE LIGHT TURNED GREEN AND UPON ACCELERATION, THE ENGINE STOPPED IN THE MIDDLE OF THE INTERSECTION.THE "FUEL PUMP" WARNING CAME UP ON MY SCREEN. THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE REPAIR SHOP WHERE IT DID NOT EXHIBIT ANY PROBLEMS, ACCORDING TO THE MECHANIC THE VEHICLE RAN FINE. NONETHELESS, THE FUEL PUMP WAS REPLACED. DROVE THE CAR FOR TWO DAYS BEFORE IT BROKE DOWN AGAIN. SAME SCENARIO, STOPPED AT A STOP SIGN, PROCEEDED TO ACCELERATE AND THE ENGINE STOPPED. VEHICLE HAD TO BE TOWED TO THE REPAIR SHOP FOR THE SECOND TIME IN THREE DAYS. AWAITING TO SEE IF A NEW HPFP WILL RESOLVE THE ISSUE.

MY 2009 BMW 535I XDRIVE HAS BEEN OWNED BY ME FOR 6 YEARS. IT HAS LESS THAN 90,000 MILES ON IT. SINCE I BECAME OWNER, IT HAD 2 FUEL PUMP FAILURES, ONE WATER PUMP FAILURE, AND NOW FUEL INJECTOR FAILURE. WHEN ITS FUEL INJECTORS FAILED ON 10/27/17, THE CAR'S ENGINE STARTED SHAKING RIGHT AFTER I TURNED IT ON. THE CAR WAS PARKED OVERNIGHT AND I PROCEEDED ON THE SIDE STREET AT 10 MILES AN HOUR SPEED TOWARDS WORK IN THE MORNING. CAR THEN LOST POWER AND WOULD NOT ACCELERATE. VERY DARK, DENSE, BLACK SMOKE WAS COMING OUT OF THE TAIL PIPE. AFTER TOWING IT TO THE DEALER BECAUSE IT WAS UNSAFE TO DRIVE, I HAVE BEEN TOLD BY BMW DEALER THAT THE FUEL INJECTORS ARE MALFUNCTIONING AND RATHER THAN SPRAYING THE FUEL INSIDE THE ENGINE, THEY WERE DUMPING IT IN LARGE AMOUNTS INSTEAD. THIS CREATED A STATE OF TOO MUCH...

FUEL PUMP CUT OUT UNEXPECTEDLY WHILE DRIVING AT POSTED SPEED LIMIT OF 60 MPH. ALMOST RUN OVER BY TRACTOR TRAILER WHILE PULLING CAR TO SIDE OF THE ROAD. CAR WAS LATER RE-STARTED.

GAS TANK WILL ONLY FILL HALF WAY BEFORE THE GAS BLOWS BACK UP THROUGH THE FILLER PIPE ONTO THE GROUND AND MY PANTS - SAFETY ISSUE

I AM REQUESTING NHTSA INVESTIGATE THIS KNOWN DANGEROUS DEFECT AND ISSUE A MANDATED RECALL TO PROTECT THE PUBLIC. FUEL PUMP FAILURE OR RELATED FAILURES CAN CAUSE A CAR TO BE UNABLE TO MOVE OUT OF A DANGEROUS HIGHWAY AFTER ENGINE POWER FAILURE AT IDLE, CAUSING RISK TO HUMAN LIFE. ON 08-08-17, I WAS ON INTERSTATE IN STOPPED TRAFFIC. MY 2009 BMW 535XI WITH 115, 502 MILES ON IT QUIT RUNNING. TRAFFIC CLEARED AND I COULD NOT GET THE VEHICLE TO START, RUN, AND MOVE. IT WOULD START, BUT IT WOULD THEN QUIT RUNNING BEFORE I COULD PLACE IT IN GEAR. INTERSTATE TRAFFIC WAS APPROACHING AT 60 TO 70 MPH. MY THREE PASSENGERS GOT OUT AND PUSHED THE VEHICLE WHILE I STEERED IT IN NEUTRAL, NOT RUNNING, OFF THE ROADWAY. WE HAD A NEAR MISS COLLISION FROM APPROACHING VEHICLES ON THE INTERSTATE. THE DASH DISPLAY SAID "HIGH PRESSURE FUEL PUMP FAILURE."...

I WAS DRIVING ON THE HIGHWAYS, AMIDST OTHER VEHICLES WHEN THE ENGINE COMPLETELY LOST POWER AND STOPPED RUNNING. I WAS VERY LUCKY THAT I DID NOT CREATE AN ACCIDENT. THE VEHICLE JUST SHUT ITSELF OFF WHILE GOING 60!! I LOST POWER STEERING BUT MANAGED TO PULL OFF TO THE SIDE OF THE ROAD. THE VEHICLE WOULD THEN NOT START AND ON THE IDRIVE IT GAVE ME A FUEL PUMP WARNING . ABOUT AN HOUR LATER AFTER CALLING FOR ASSISTANCE, I STARTED THE VEHICLE AND IT WAS AS IF NOTHING HAD OCCURED. THE WARNING DISSAPPEARING AND IT DROVE NORMALLY. IT HAS SINCE THEN DONE THIS SAME THING 4 OTHER TIMES. I HAVE READ MANY OTHER COMPLAINTS SIMILAR TO MINE AND WANT TO KNOW IF THIS VEHICLE IS RECALLED AND IF NOT THEN WHY IS IT NOT RECALLED?

TAKATA RECALL. THE VEHICLE JUST SHUTS RIGHT OFF WITHOUT ANY WARNING SIGN OR CHECK ENGINE LIGHT. THE VEHICLE LOSES POWER ON THE HIGHWAY WITHOUT ANY WARNING SIGN AND IT'S ABSOLUTELY DANGEROUS AND IT CAN CAUSES A SERIOUS ACCIDENT. BMW HAS ISSUED A RECALL ON LATER MODELS BUT NOT THIS MODEL. ONCE THE VEHICLE TURNS COMPLETELY OFF A MESSAGE ON THE VEHICLES IDRIVE DISPLAYS "FUEL PUMP FAILURE." AFTER THE VEHICLE COOLS DOWN FOR 20-30 MINUTES IT STARTS BACK UP AND IT HAPPENS AGAIN WITHOUT NOTICE MAYBE DAYS LATER OR WEEKS LATER. IT'S A DANGEROUS ISSUE AND THERE'S NO WAY TO DETECT IT SO WARRANTY COMPANIES ARE GIVING A HARD TIME TO COVER THE COSTS AND IT'S LISTED AS COVERED UNDER EXTENDED WARRANTY. VERY DANGEROUS ISSUE AND IT'S SOMETHING BMW SHOULD LOOK INTO WITH THE OLDER MODEL AS WELL. CURRENTLY THERE'S A RECALL ON THE 2010-2011 MODELS FOR DOING THE SAME EXACT...

MY 2009 BMW 535I X DRIVE CONTINUES TO HAVE STALLING ISSUES. I'M TIRED OF TAKING IT IN TO BMW TO HAVE THEM CHARGE ME AND SAY NOTHING IS WRONG JUST TO HAVE MY CAR CONSTANTLY SHUTTING DOWN OVER AND OVER. MY CAR HAS PRETTY MUCH BEEN REBUILT BECAUSE OF THIS ISSUE AND IT CONTINUES TO HAPPEN. I DO NOT FEEL THAT I SHOULD HAVE TO KEEP PAYING FOR A PROBLEM THAT IS NOT RESOLVED. MY HIGH PRESSURE FUEL PUMP, FUEL PUMP, BATTERY, HIGH AND LOW PRESSURE SENORS HAVE BEEN REPLACED. I'VE HAD MY OIL CHANGED AND FUEL LINE FLUSHED AND THE PROBLEM IS STILL OCCURRING. I TRULY ENJOY THE VEHICLE WHEN ITS WORKING BUT I'M JUST AT THE POINT OF TRADING IT IN FOR ANOTHER VEHICLE OTHER THEN BMW.

FUEL PUMP!, NEAR THE GAS TANK. I CAN'T GO VERY FAR IN MY CAR WITHOUT IT CUTTING OFF. I HAVE HAD IT DIAGNOSED BY BMW. I HAVE BEEN TOWED OFF THE HIGHWAY ( GRAND CENTRAL EXIT 19) WHILE BEING STUCK IN AN UNSAFE CONDITION ON 10/13/16. I HEAR 3 CONSECUTIVE BEEPS THEN WITHIN 5 MINUTES OR LESS THE CAR SHUTS DOWN AND THE SYSTEM SHOWS FUEL PUMP!. I HAVE HAD THE HIGH PRESSURE FUEL PUMP REPLACE BY BMW, HOWEVER THAT DOES NOT SEEM TO BE THE PROBLEM. I AM NOT ENJOYING MY CAR. THE RECALL ANNOUNCED ON 10/28/2016, SHOULD ALSO INCLUDE THE 2009 BMW 5 SERIES. I LOVE THE BMW CARS, HOWEVER IT HAS BECOME THE ULTIMATE DRIVING NIGHTMARE. PLEASE INCLUDE THE 2009 SERIES IN THE RECALL. *TR

THE CAR ENGINE *COMPLETELY* SHUTDOWN WHILE BEING DRIVEN, *WITHOUT* ANY WARNING; HAD JUST EXITED MAJOR INTERSTATE HIGHWAY (I-95), AND WAS STILL ON EXIT RAMP WHEN THIS HAPPENED. THE CAR WAS STILL IN MOTION, THE DRIVER, LUCKILY, WAS ABLE TO BRING THE CAR TO THE SIDE OF THE RAMP WITHOUT ANY OTHER DAMAGE. DIAGNOSIS BY NEAREST BMW DEALER SERVICE INDICATED A SIMULTANEOUS SHORT CIRCUIT IN THE EKPS (CONTROLLER?) MODULE, A FAULT IN THE MAIN (LOW PRESSURE) FUEL PUMP AND ANOTHER SHORT CIRCUIT IN FUEL PRESSURE SENSOR. ALL THIS HAPPENED, SIMULTANEOUSLY, WITHOUT WARNING, IN A VERY WELL MAINTAINED, DEALER-SERVICED, LOW MILEAGE (42000 MILES) BMW 535I (YR 2009) VEHICLE. THE FACT THAT THE ENGINE *COMPLETELY* SHUTDOWN, ON AN EXIT RAMP OF A MAJOR HIGHWAY, AND COULD NOT BE RESTARTED CREATED A VERY HAZARDOUS CONDITION FOR THE DRIVER OF THE VEHICLE AND FOR OTHER DRIVERS ON THE ROAD WAS WELL. HAD THIS HAPPENED ON...

TAKATA RECALL, I BOUGHT THE CAR BACK IN LATE AUGUST, AT A DEALERSHIP CALLED DELUXE AUTO LOCATED IN LINDEN, NEW JERSEY. THE DEALERSHIP OFFERED ME A WARRANTY, 30 DAYS FREE AND 90 DAYS TO DECIDE TO GET THE WARRANTY OR NOT. THE INITIAL OFFER WAS ABOUT 60$ MONTHLY, AT 79K MILES. AFTER HAVING THE CAR FOR A MONTH DRIVING ON THE HIGHWAY LATE AT NIGHT THE CAR STARTING SHAKING AND TURNED OFF ON THE HIGHWAY. FUEL PUMP ERRORS. CAR WAS TOWED OFF THE HIGHWAY. AFTER A FEW HRS CAR STARTED AND RAN NORMALLY. WENT TO THE DEALERSHIP, GOT WARRANTY. THE OFFER NOW WAS AT 120$ A MONTH. THEY DID THE JOB, CAR RAN NORMALLY. HAPPENED AGAIN IN BROOKLYN, SENT CAR BACK TO DEALER THEY SAID NOTHING CAME UP ON THE COMPUTER, NOTHING THEY CAN DO. AFTER A FEW MONTHS SAME THING HAPPENED. THIS TIME IN CONNECTICUT, SENT IT TO THE...

CAR STOPPED WHILE ON FREEWAY MOVING AT 50 MILES PER HOUR WITH MY VISUALLY IMPAIRED GRANDCHILD VERY SCARY. WARNING LIGHT CAME ON FUEL PUMP MALFUNCTION AND CAR JUST STOPPED. TOOK IT TO CONRAD THEY SAY IT IS THE HIGH PRESSURE FUEL PUMP AND I NEED TO TAKE IT TO BMW UNDER RECALL BMW SAYS IT IS THE LOW PRESSURE FUEL PUMP BUT THEY ARE NOT SURE IT WILL FIX THE PROBLEM. BMW NEED TO FIX THIS PROBLEM I THANK GOD WE WERE NOT HIT YESTERDAY ON THE FREEWAY.

DRIVING ON THE HIGHWAY, ENGINE STOPS. FIRST WARNING "ENGINE MALFUNCTION, REDUCED POWER. BUT IT HAD ALREADY STOPPED. AFTER NARROWING MISSING TRAFFIC PARKED IN BREAKDOWN LANE. NEXT WARNING FUEL PUMP FAILURE. CAR WOULD NOT RE-START FOR AN HOUR UNTIL TOW TRUCK ARRIVED. HAD TO BE TOWED TO BMW DEALER. DEALER REPORTS LOW PRESSURE FUEL PUMP. ENGINE DIED AGAIN AT DEALERS

THE CAR SUDDENLY DISPLAYED A WARNING SAYING THE FUEL PUMP MALFUNCTION AND GAVE A NOTICE THAT ENGINE MAY SHUTDOWN IMMEDIATELY AND TO PULL TO A SIDE. WE COMPLIED - THOUGH IT MAY HAVE BEEN PRETTY DANGEROUS IF WE WERE ON HIGHWAYS OR IN TRAFFIC. TRIED TO START AGAIN, THE SAME ISSUE. GOT IT TOED TO THE BMW DEALERSHIP. THE DEALER DIAGNOSED THE ISSUE TO BE THE HIGH PRESSURE INJECTION PUMP AND TOLD US IT IS NOT COVERED. WE CALLED BMW AND THEY TOLD IT IS NOW COVERED AS IT HAS AN EXTENDED WARRANTY. WE TELL THE DEALER AND THE DEALER TELLS US IT IS COVERED BUT ANOTHER PART EDK PF IS NOW NOT COVERED AS IT DID SHOW FAULT CODES THAT WERE EARLIER THAN THE FUEL PUMP FAULT CODES. MY ISSUE IS IF THE FUEL PUMP AND EDK WORK HAND-IN-HAND, WON'T THE TWO TO BE COVERED BY BMW? WHY IT...

VEHICLE SHUTTERS AND MISFIRES WHEN AUTOMATIC TRANSMISSION DOWNSHIFTS WHILE ATTEMPTING TO ACCELERATE AT CRUISING SPEEDS. ENGINE LIGHT COMES ON AND HAS REDUCED POWER UNTIL VEHICLE IS RESTARTED. MAJOR SAFETY CONCERN WHEN ATTEMPTING TO MERGE ONTO HIGHWAY.

I WAS DRIVING ON THE HIGHWAY AND ALL OF A SUDDEN WHEN I TRIED TO SWITCH LANES, THE CAR JUST MADE A BIG FUMBLE AND ALMOST STALLED. THE TRAFFIC BEHIND NEARLY BECAME FATAL AS THE CAR DID NOT ACCELERATE AND I WAS VERY LUCK TO HAVE PULLED BACK WITH THE PASSING CAR BARELY HITTING MY MIRROR. I HAVE TAKEN THIS CAR TO THE DEALER ON MANY OCCASIONS AND THEY HAVE CHANGED OUT ALL THE INJECTORS AND STILL THE CAR IS HAVING THIS PROBLEM. EVERY TIME I GO TO THE DEALER THEY KEEP CHANGING THE FUEL INJECTORS OR RECALIBRATING THEM. A SIMPLE GOOGLE SEARCH WILL SHOW THAT THIS IS AN ON GOING ISSUE WITH THESE CARS AND BMW OF NORTH AMERICA DOES NOT WANT TO DO ANYTHING ABOUT IT. EVEN THOUGH THIS WAS REPORTED BEFORE THE END OF THE MANUFACTURER'S WARRANTY AND STILL ONGOING, THEY REFUSE TO COVER THE REPAIRS. THIS...

IN THE 4 1/2 YEARS THAT MY 535XI HAS BEEN IN SERVICE, THE FUEL INJECTORS HAVE NEEDED TO BE REPLACED 3 TIMES (SEPT 2011, JAN 2013, AND SEPT 2014). THE PROBLEMS HAVE MANIFESTED THEMSELVES WHEN DRIVING ON HIGHWAYS AND THE VEHICLE LOSES MOST POWER AND BEGINS SHAKING AND THE CHECK ENGINE GASES LIGHT COMES ON. THE MOST RECENT TIME OCCURRED WHILE ON AN INTERSTATE TOLLWAY BETWEEN EXITS 15 MILES APART MAKING FOR A DANGEROUS SITUATION AS I LOST SPEED AND ANY ABILITY TO ACCELERATE. EFFORTS TO HAVE BMW COVER THE REPAIRS (ESTIMATED AT $2,200 INCLUDING NEW PLUGS), WERE BOTH UNSUCCESSFUL AND FRUSTRATING. THE DEALER PROVIDED ZERO ASSISTANCE. I CONTACTED BMW NA AND STATED THAT HAVING TO REPLACE THE FUEL INJECTORS 3 TIMES IN 4 1/2 YEARS INDICATES A DEFECTIVE DESIGN AND RESULTS IN DANGEROUS SITUATIONS. I WAS TOLD THAT THEY WOULD INVESTIGATE AND INFORM ME WHETHER THE REPAIRS WOULD BE...

MY FIRST INCIDENT OCCURRED WHILE I WAS TRAVELING ON I-185. MY VEHICLE SUDDENLY LOST POWER AND BEGAN SPUTTERING AND CHECK ENGINE LIGHT CAME ON. THIS HAPPENED WHILE TRAFFIC WAS HEAVY BUT MIRACULOUSLY I WAS ABLE TO MERGE OVER TO THE EMERGENCY LANE AND EXIT OFF THE INTERSTATE. BMW DEALERSHIP DIAGNOSIS IT AS A FAILED IN-TANK ELECTRIC FUEL PUMP AND SENSOR. IT WAS REPAIRED AND I PAID 1254.00. UNFORTUNATELY, A WEEK LATER, I EXPERIENCED ANOTHER LOSS OF ENGINE POWER AND CHECK ENGINE LIGHT CAME ON WHILE I WAS TRAVELING ON THE INTERSTATE. THIS TIME BMW DEALERSHIP TOLD ME THEY HAD TO UPGRADE SOFTWARE AND CHANGE OUT SOME INJECTORS AND THAT SHOULD SOLVE MY PROBLEM. I BOUGHT THIS CAR TO DRIVE IT AND NOT SEND IT BACK AND FORTH TO THE REPAIR SHOP. *TR