2005 BIGDOG RIDGEBACK — Problems, Recalls & Safety Data
N/A
Safety Rating
4
Owner Complaints
6
Recalls
2
Service Bulletins
0
Investigations
Overview of the 2005 BIGDOG RIDGEBACK
The 2005 BIGDOG RIDGEBACK has received a total of 4 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 6 recall campaigns affecting this vehicle, covering issues with WHEELS:HUBCAP/COVER, ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR, ELECTRICAL SYSTEM. 2 technical service bulletins have been issued by Big Dog Motorcycles, LLC for this model year. The most commonly reported problems involve the Electrical Systemignitionmodule (1 complaint), Power Train (1 complaint), and Service Brakes Hydraulicfoundation Componentsdisccaliper (1 complaint).
Recalls for the 2005 BIGDOG RIDGEBACK
NHTSA has recorded 6 recalls for the 2005 BIGDOG RIDGEBACK, potentially affecting up to 25,407 vehicles.
Recall 09V147000 — WHEELS:HUBCAP/COVER
| 1,257 vehicles affected
Defect: BIG DOG IS RECALLING 1,257 MY 2005 RIDGEBACK MOTORCYCLES. THE REAR WHEEL MAY HAVE WEAK SPOTS IN THE DESIGN, WHICH MAY CAUSE THE WHEEL TO CRACK UNDER CERTAIN OPERATING CONDITIONS.
Consequence: IF UNDETECTED, THIS CONDITION MAY LEAD TO A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WHEELS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2009. OWNERS MAY CONTACT BIG DOG MOTORCYCLES CUSTOMER SERVICE DEPARTMENT AT 1-316-267-9121.
View full details →Recall 07V356000 — ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
| 7,611 vehicles affected
Defect: ON CERTAIN MOTORCYCLES, A WARPED BUS BAR WITHIN THE VOLTAGE REGULATOR CAN CAUSE A SHORT CIRCUIT.
Consequence: THIS COULD POSSIBLY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE EXISTING CIRCUIT BREAKER LOCATED BETWEEN THE VOLTAGE REGULATOR POSITIVE BATTERY LEAD (B+ LEAD) AND THE POSITIVE BATTERY TERMINAL WITH AN ALTERNATIVE CIRCUIT PROTECTION DEVICE THAT WILL PREVENT A THERMAL EVENT IF THERE IS A SHORT TO...
View full details →Recall 06V305000 — ELECTRICAL SYSTEM
| 2,101 vehicles affected
Defect: ON CERTAIN MOTORCYCLES, THE ELECTRONIC HARNESS CONTROL (EHC) MODULE CAN FAIL RESULTING IN A TOTAL SHUT DOWN OF THE VEHICLE'S ELECTRONIC POWER.
Consequence: THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE EHC MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 19, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
View full details →Recall 06V019000 — STRUCTURE:MOTORCYCLE:KICKSTAND/CENTER STAND
| 9,726 vehicles affected
Defect: ON CERTAIN MOTORCYCLES, THE KICKSTAND SPRING MAY STRETCH AND DETACH FROM THE MOUNTING BRACKET OR THE KICKSTAND.
Consequence: THIS WILL ALLOW THE KICKSTAND TO DEPLOY INTO THE EXTENDED POSITION AND CAUSE A CRASH.
Remedy: DEALERS WILL INSTALL A NEW KICKSTAND SPRING FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 17, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
View full details →Recall 05V432000 — WHEELS:LUGS/NUTS/BOLTS/STUDS
| 3,294 vehicles affected
Defect: ON CERTAIN MOTORCYCLES, THE REAR WHEEL HUB BOLTS COULD LOOSEN AND BACK OUT ALLOWING THE HUB AND BRAKE ROTOR TO DETACH FROM THE WHEEL WITH AN ASSOCIATED LOSS OF STOPPING POWER.
Consequence: THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REMOVE, CLEAN AND REATTACH THE REAR HUB BOLTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 14, 2005. OWNERS MAY CONTACT BIG DOG AT 1-312-267-9121.
View full details →Recall 05V149000 — POWER TRAIN
| 1,418 vehicles affected
Defect: ON CERTAIN MOTORCYCLES, THE PRIMARY DRIVE SPROCKET NUT MAY BACK OFF THE ENGINE MAIN SHAFT.
Consequence: THIS COULD CAUSE THE PRIMARY DRIVE TO LOCK UP AND CAUSE A CRASH. THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND REPLACE THE DRIVE SPROCKET NUT FREE OF CHARGE. THE RECALL BEGAN ON MAY 13, 2005. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
View full details →Owner Complaints for the 2005 BIGDOG RIDGEBACK
4 complaints have been filed with NHTSA for the 2005 BIGDOG RIDGEBACK. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Electrical Systemignitionmodule | 1 | 0 | 0 | 0 | 0 |
| Power Train | 1 | 0 | 0 | 0 | 0 |
| Service Brakes Hydraulicfoundation Componentsdisccaliper | 1 | 0 | 0 | 0 | 0 |
| Service Brakes Hydraulicfoundation Componentsdiscrotor | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
IMMEDIATELY AFTER PURCHASING MY 2005 BIG DOG RIDGEBACK, MULTIPLE PROBLEMS BEGAN TO ARISE. THE BIKE WOULD RANDOMLY SHUT OFF FOR NO APPARENT REASON, ALSO IT HAD AN EVER INCREASING SQUEAL THAT EVENTUALLY BECAME LOUDER THAN THE ENGINE. THE DEALER THAT THE BIKE WAS PURCHASED FROM WAS UNABLE TO REPAIR THE ISSUES AND WAS DISHONEST ABOUT THE SERVICE THAT THEY WERE SUPPOSED TO DO. EVENTUALLY THAT DEALER REFUNDED THE MONEY FOR MY FIRST SERVICE AND PAID ME BACK FOR MOST OF THE DAMAGE THAT WAS DONE TO MY BIKE. OBVIOUSLY I NO LONGER WISH TO BRING MY BIKE THERE FOR SERVICE. AFTER REALIZING THAT THERE WERE NO FACTORY SERVICE CENTERS WITHIN A REASONABLE DISTANCE, I CONTACTED THE BIG DOG FACTORY AND WAS GIVEN THE RUN AROUND. I EVEN TRAILERED THE BIKE TO DAYTONA WHERE THE FACTORY MECHANIC DID A NON-APPROVED REPAIR ON THE SQUEAL, BUT THIS IS A TEMPORARY FIX THAT NEEDS TO BE ADDRESSED. SINCE DAYTONA THE FACTORY HAS FAILED TO REMEDY MY PROBLEMS INCLUDING THE FRONT AND REAR HUB BOLTS ARE COMING LOOSE, THE ENGINE STILL SHUTS OFF RANDOMLY, AND THE RE-MACHINING OF THE FRONT PULLEY COULD LEAD TO A BELT FAILURE AT HIGHWAY SPEEDS. I'T APPEARS THAT SEVERAL OF MY BIKES ISSUES WERE ACTUALLY RECALLS THAT BOTH THE DEALER AND THE FACTORY HAVE IGGNORED. HELP!!!!!!!!!!!! THIS BIKE IS UNSAFE!!!! *JB
IMMEDIATELY AFTER PURCHASING MY 2005 BIG DOG RIDGEBACK, MULTIPLE PROBLEMS BEGAN TO ARISE. THE BIKE WOULD RANDOMLY SHUT OFF FOR NO APPARENT REASON, ALSO IT HAD AN EVER INCREASING SQUEAL THAT EVENTUALLY BECAME LOUDER THAN THE ENGINE. THE DEALER THAT THE BIKE WAS PURCHASED FROM WAS UNABLE TO REPAIR THE ISSUES AND WAS DISHONEST ABOUT THE SERVICE THAT THEY WERE SUPPOSED TO DO. EVENTUALLY THAT DEALER REFUNDED THE MONEY FOR MY FIRST SERVICE AND PAID ME BACK FOR MOST OF THE DAMAGE THAT WAS DONE TO MY BIKE. OBVIOUSLY I NO LONGER WISH TO BRING MY BIKE THERE FOR SERVICE. AFTER REALIZING THAT THERE WERE NO FACTORY SERVICE CENTERS WITHIN A REASONABLE DISTANCE, I CONTACTED THE BIG DOG FACTORY AND WAS GIVEN THE RUN AROUND. I EVEN TRAILERED THE BIKE TO DAYTONA WHERE THE FACTORY MECHANIC DID A NON-APPROVED REPAIR ON THE SQUEAL, BUT THIS IS A TEMPORARY FIX THAT NEEDS TO BE ADDRESSED. SINCE DAYTONA THE FACTORY HAS FAILED TO REMEDY MY PROBLEMS INCLUDING THE FRONT AND REAR HUB BOLTS ARE COMING LOOSE, THE ENGINE STILL SHUTS OFF RANDOMLY, AND THE RE-MACHINING OF THE FRONT PULLEY COULD LEAD TO A BELT FAILURE AT HIGHWAY SPEEDS. I'T APPEARS THAT SEVERAL OF MY BIKES ISSUES WERE ACTUALLY RECALLS THAT BOTH THE DEALER AND THE FACTORY HAVE IGGNORED. HELP!!!!!!!!!!!! THIS BIKE IS UNSAFE!!!! *JB
IMMEDIATELY AFTER PURCHASING MY 2005 BIG DOG RIDGEBACK, MULTIPLE PROBLEMS BEGAN TO ARISE. THE BIKE WOULD RANDOMLY SHUT OFF FOR NO APPARENT REASON, ALSO IT HAD AN EVER INCREASING SQUEAL THAT EVENTUALLY BECAME LOUDER THAN THE ENGINE. THE DEALER THAT THE BIKE WAS PURCHASED FROM WAS UNABLE TO REPAIR THE ISSUES AND WAS DISHONEST ABOUT THE SERVICE THAT THEY WERE SUPPOSED TO DO. EVENTUALLY THAT DEALER REFUNDED THE MONEY FOR MY FIRST SERVICE AND PAID ME BACK FOR MOST OF THE DAMAGE THAT WAS DONE TO MY BIKE. OBVIOUSLY I NO LONGER WISH TO BRING MY BIKE THERE FOR SERVICE. AFTER REALIZING THAT THERE WERE NO FACTORY SERVICE CENTERS WITHIN A REASONABLE DISTANCE, I CONTACTED THE BIG DOG FACTORY AND WAS GIVEN THE RUN AROUND. I EVEN TRAILERED THE BIKE TO DAYTONA WHERE THE FACTORY MECHANIC DID A NON-APPROVED REPAIR ON THE SQUEAL, BUT THIS IS A TEMPORARY FIX THAT NEEDS TO BE ADDRESSED. SINCE DAYTONA THE FACTORY HAS FAILED TO REMEDY MY PROBLEMS INCLUDING THE FRONT AND REAR HUB BOLTS ARE COMING LOOSE, THE ENGINE STILL SHUTS OFF RANDOMLY, AND THE RE-MACHINING OF THE FRONT PULLEY COULD LEAD TO A BELT FAILURE AT HIGHWAY SPEEDS. I'T APPEARS THAT SEVERAL OF MY BIKES ISSUES WERE ACTUALLY RECALLS THAT BOTH THE DEALER AND THE FACTORY HAVE IGGNORED. HELP!!!!!!!!!!!! THIS BIKE IS UNSAFE!!!! *JB
THE TWO BOLTS HOLDING THE FRONT CALIPER ON MY 2005 BIGDOG RIDGEBACK BACKED OUT. I DISCOVERED IT AFTER RIDING THE MOTORCYCLE. THE TWO BOLTS HAD BACKED OUT TO WHERE THEY WERE BEING HELD BY A COUPLE OF THREADS. I THEN REMOVED THE BOLTS, AND FOUND THAT THERE WAS ABSOLUTELY NO" LOCKTITE" APPLIED TO EITHER OF THE BOLTS. IF THE FRONT CALIPER FALLS OFF WHILE RIDING, IT COULD BE CATASTROPHIC. I PURCHASED SOME "LOCKTITE", AND APPLIED IT TO THE BOLT THREADS, AND REINSTALLED THE BOLTS. *JB
Safety Rating for the 2005 BIGDOG RIDGEBACK
NHTSA has not yet tested the 2005 BIGDOG RIDGEBACK in its New Car Assessment Program.
Technical Service Bulletins for the 2005 BIGDOG RIDGEBACK
Big Dog Motorcycles, LLC has issued 2 technical service bulletins (TSBs) for the 2005 BIGDOG RIDGEBACK. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
1061 — ENGINE AND ENGINE COOLING:ENGINE
1/2 - 20 INCH UPPER ENGINE MOUNT BOLT RETENTION. BIG DOG. *TT
1060 — STRUCTURE
SEAT PAN CONTACT WITH LEFT REAR CORNER AND EDGE OF BATTERY CASE. *TT
NHTSA Investigations for the 2005 BIGDOG RIDGEBACK
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the BIGDOG RIDGEBACK
- 2004 BIGDOG RIDGEBACK — 5 complaints
- 2005 BIGDOG RIDGEBACK (current)
- 2006 BIGDOG RIDGEBACK — 0 complaints
- 2008 BIGDOG RIDGEBACK — 0 complaints
Other BIGDOG Models
- BIGDOG CHOPPER — 23 total complaints
- BIGDOG PITBULL — 13 total complaints
- BIGDOG MASTIFF — 6 total complaints
- BIGDOG DAYTEC CHOPPER — 4 total complaints
- BIGDOG BULL DOG — 3 total complaints
- BIGDOG BIG DOG — 2 total complaints
- BIGDOG PIT BULL — 2 total complaints
- BIGDOG BDM — 1 total complaint