2022 ACURA MDX Power Train Problems

While driving in snow and in light rain noticed the MDX pulling and slipping. I realized that only the front tires were trying to drive the vehicle which was causing the car to pull sideways and slip all over the road. I made an appointment with the ACURA dealership and they found the transmission splines stripped out that drive the rear wheels. There was no warning lamps or indication that anything was broke other than very hard to drive in any kind of snow or rain. Talking with the dealer and looking online this seems to be happening to other MDX s also. My car was fixed under the manufacturer warranty and the transmission and transfer case were replaced.

While driving a 2022 Acura MDX Advance AWD in snowy conditions, I noticed reduced traction and abnormal drivability. Dealer inspection confirmed a catastrophic failure: the front differential and transmission splines were stripped, causing the vehicle to operate in front-wheel drive only. The dealer verified the failure and documented it as a defect on the repair order. The vehicle was maintained exclusively at the dealership since new, and failure occurred at approximately 76,000 miles, outside the original powertrain warranty. There were no warning lights prior to the failure, but loss of AWD in snowy conditions created a significant safety risk.This is a safety-relevant defect affecting traction and stability in adverse conditions.

My Acura service department notified me at my last oil change that they discovered (accidentally) my transmission / transfer case is damaged and is not transferring power to the rear wheels, rendering the vehicle as 2 wheel drive only. This requires a total replacement costing $16,000 +/-. My research indicates this is likely caused by a faulty splined shaft inside the transmission-transfer case assembly used in the early 2022 MDX vehicles.The dashboard info system for SH-AWD indicates that the car IS in All Wheel Drive and there are no messages indicating a problem with the All Wheel Drive. This has not been a problem during non-snow or other slippery conditions, but recent storms have made this a major safety problem for me. The fact that the car sensing system does not detect this problem could cause serious driving danger for unsuspecting drivers. This also prevents Acura/Honda from acting on this...

The vehicle is experiencing a catastrophic mechanical failure of the transfer case/transmission splines, resulting in a 'Loss of Motive Power.' On two occasions while merging into high-speed highway traffic, the engine revved to high RPMs, but the vehicle failed to accelerate for approximately 5 seconds (Mechanical Neutral Drop). These incidents resulted in near-collisions. The vehicle also exhibits violent torque steer and unpredictable handling. The issue was initially reported to an authorized dealer at 70,320 miles but was misdiagnosed as 'no codes were present.' Subsequent inspection by a second dealer confirmed a mechanical failure of the drive splines. This is a purely mechanical failure that does not trigger dashboard warning lights or Diagnostic Trouble Codes (DTCs), leaving the driver unaware of the impending drivetrain failure until power is lost. First signs of a problem: Late August 2025 First loss of motive power incident: Early October 2025 Second loss of motive power...

Vehicle is 3 years old with 60K miles. Transfer case became defective under normal driving and with regular recommended maintenance. We did not know this occurred until a recent dealership visit for another issue. We do not know how long this has been an issue. When the transfer case malfunctioned, there were no warning lights and vehicle has been only functioning in front-wheel drive (designed to be AWD) which is extremely dangerous during the midwestern winters as the weight of the rear of the vehicle leads to sway. Issue was detected by the dealership who states the fix is to replace the entire transmission and transfer case.

When the vehicle decelerates—either from high speed or while already moving slowly—it frequently jerks just before coming to a complete stop. This issue is especially noticeable at very low speeds or during final braking, where the vehicle may lurch forward by a few inches unless the brakes are applied firmly. Despite multiple visits to the dealership, including transmission resets and software updates, the problem persists. The dealer has not provided a resolution or adequate follow-up. This behavior poses a serious safety risk, particularly in high-traffic areas where precise stopping is critical.

The transmission and transaxle malfunctioned. Evidence was a leak from the transaxle. The dealer confirmed that the vehicle was operating in 2WD mode even though it did not detect any issues from its onboard sensors, and the car thought it was still sending power to all 4 wheels. There were no warning lights that the vehicle was no longer driving in 4wd mode, so the driving dynamics would've been unexpected in conditions that 4wd would normally help, like rain and snow. Unexpectedly experienced tire spin in the rain, for example. The dealer confirmed that both the transmission and transaxle need to be replaced, under the powertrain warranty. The spline between the transaxle and transmission were worn, causing the transaxle to not spin the rear wheels.

The transfer case spline stripped preventing power to be sent to the rear wheels

Upon normal highway driving a couple of months ago, began to notice shifting that was not smooth and rpm "surges" on hills despite constant throttle. Upon taking car to dealer, inspection revealed an internal spline failure between transmission and transfer case. Lead mechanic explained it was not the first he had seen of this model and that it was clearly internal and caused by a manufacturing and/or assembly defect. I caught the problem early enough to not have a complete car failure; however, left untreated, it would lead to a transmission failure. The remedy was a full transmission and transfer case replacement, with repair costs exceeding $13,000. Given car had 84,000 miles, it was not covered by 70,000 Power Train Warranty from Acura. Pictures of parts below.

Acura Headquarters USA 1919 Torrence Boulevard Torrence, California 90501 Mr. [XXX] [XXX] [XXX] Email: [XXX] Dear Sir or Madam, I am writing your company to the attention of whomever oversees the product development and design of the 2022 ACURA MDX and to warn them that certain system features and design flaws of this make and model vehicle will undoubtedly lead to the death of someone in the near future as was nearly the case with myself and spouse very recently. On Sunday [XXX], my spouse and I attended church services that morning. Fortunately, after services our Acura MDX did start as usual, and we began our journey home.Upom arriving home, we backed our car into our garage and during that process thankfully I had the wits to unlock the passenger and driver side door mechanisms. Once we enteredthe garage and at thta point, our car went absolutely DEAD. Our car...

Many attempts in the last 5k miles made to diagnose unsafe uncomfortable front vibrations. Vehicle erratically shaking above 50mph. Returned vehicle to CarMax (where vehicle purchased), and 3 separate individual Acura dealers made attempts. Rotated and rebalanced tires several times with a scan tool connected as a technician drove vehicle with no results Finally Acura dealer an hour away from my home diagnosed faulty front transfer case pending anything further. Conveyed the shaft splines into transfer case and other end to transmission may be faulty, rounded out, and will report findings. After inspected, transmission output splines for shaft going to front transfer case have been found rounded out as well. Dealer reported this again under warranty and ordering transmission. Coming up on 30 days front transfer case, transmission, and possibility of further repairs. Compiling written documentation. Vehicle repair attempts at Carmax Newport News, VA, Southern Acura Newport News, VA, Hall...

We were at a stop sign. I went to hit the gas and then a warning flash on the screen that there is a problem with the rear axle of the all wheel drive and that it was switching to front drive only. During that 5-10 seconds we went through the intersection on creep mode, 2-5 mph max. I felt helpless. My wife has had it happen to her 2 times. My first experience was tonight and it could have been bad if there was a car on the road we were crossing.

driving on highway car suddenly lost power check engine light came on. was able to coast off to an exit on the highway. car eventually unable to move. the car was towed to the dealer. the transmission and power take off unit was replaced.

My vehicle has 80,000 miles. It has a popping sound when accelerating from stop. Dealership found metal chunks in the transmission and transfer case. Luckily I brought the problem to them before catastrophic failure while driving. Both are needing complete replacements.

My transfer case went out at an unknown mileage with no indication on my dash that there was a failure. It converted the vehicle to front wheel drive while indicating it was still having the back wheel spinning on the all-wheel drive indicator on the dash. During a recent snowstorm, there were multiple instances when I pulled out from an intersection thinking I had good traction I'm pulled out and then my wheels started spinning almost causing an accident. I thought that was weird so I brought it to my local Acura dealer and explained what happened and they tested it and found that the transfer case splines were bad along with the splines that attached to the transmission. They replaced both the transmission and transfer case under warranty. No police or insurance representatives were involved as there were no accidents.

Front driver wheel has started to spin when power applied from a stop or from a slow roll. Tires are in great condition, further research indicates that this is a typical issue between the transfer case and differential. Splines get stripped and the car essentially becomes 2 wheel drive. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There were two major failures in my vehicle within a couple of weeks. The first was a lower ball joint failure. The passenger side lower control arm was replaced. The second major failure was the transfer case seal on the transmission failed and the transmission is being replaced. The vehicle has been serviced since its new purchase at Acura dealerships.

Transmission issue… grinding and not accelerating…. When it is at a stop and moving again .. turning with accelerating.. it moves really slow

After 4 times of taking the vehicle to two dealerships for the same concerns, I am having the following problems with my vehicle at this time:: wind/whistling/whining noise heard while driving and has gone unresolved. The car consistently makes a whining/whistling noise when reaching speeds between 40-65mph and has been a known issue with this year make and model per documentation provided to me by the dealership.

The vehicle makes noise while shifting from Park to Reverse to Drive. Transmission fluid and oil fluid leaking while I had driven only 450 miles. Had reported the issue to the Service Department. They informed that since the engine is new it will take a while for the transmission gear to quiet it down. They can't find any leakage for the first two times when I brought the vehicle for them to inspect. Their Service Manager was able to identify the issue and assigned the technician to trace it down. My car is currently in their shop for the third time since I just purchased it on August 19th, 2021.

A transmission error popped up on the car and the vehicle would not accelerate past a few miles per hour. The issue is happening intermittently and the dealer and Acura service claims it’s a random issue. A sign that says brake fault keeps popping up as well and it’s really scary to drive the car. Acura service said it’s normal and working as designed and there is no fix at the moment

Transmission failed right as I drove off the lot. The car initially started to jerk and then was revving to 7000rpms and would not speed up past 25mph. The car also stopped moving when I put it in reverse. When I tool it back to the lot within the hour, around 3 days later they told me the transmission failed ln the car. This was a brand new car and should not have happened.

I purchased the new MDX 2022 on May 27th 2021. On May 31st, while driving on the Interstate 287 at 65mph, the car suddenly stop accelerating. When I pushed the gas pedal, the engine only revved up but the car continued to slow down. I pulled the car on the shoulder lane, shut the engine off and restarted. The problem continued. The dashboard had the warning sign "Transmission System Problem. Avoid heavy Acceleration and high speed. See your dealer". It also showed the sign "Emission System problem, power may be reduced. See your dealer". The problem occured on the busy interstate 287 in central Jersey without any prior warning, on a brand new MDX 2022. We were lucky since it was 11pm and we were in right lane, so could pull over the shoulder. In the online forums, I have found one more user with the similar problem. The Acura...