NHTSA Complaint #11695524 — 2019 HYUNDAI SANTA FE

I purchased my 2019 Hyundai Santa Fe on October 29, 2021. Since then, I’ve experienced a series of mechanical and electrical failures that I believe are far beyond normal for a vehicle of this age. - The remote start has never worked. - On October 20, 2023, the hatch latch failed. The only way to open it now is by climbing into the back and manually pulling the latch. - On October 27, 2023, the electric power steering failed. I had to replace the entire steering column at a cost of $4,000. - The paint began deteriorating prematurely and required a full repair. Hyundai covered this under warranty, but the cost was $8,000. - In early spring 2025, all coil packs had to be replaced due to misfires, costing approximately $500. - September 4, 2025, The car stalled while I was driving on a main road and I had to pull over. There were no warning lights and I started home. About a mile from home check engine light came on so contact mechanic. Ended up towing to a dealership and was told the engine must be replaced because the oil had burned off without any warning from the oil light indicator. The turbo also needs replacement. - The combined cost is $14,000. These failures have caused significant financial hardship and stress. I am currently $17,000 underwater on the loan, and the repair costs are overwhelming. The lack of warning before catastrophic engine damage is especially concerning. I believe these issues reflect systemic defects in the vehicle’s design and manufacturing. The repeated failure of critical components—especially the steering system and oil monitoring—make this the worst automotive experience I’ve ever had. I respectfully request that the NHTSA investigate these failures and determine whether Hyundai should be held accountable. Consumers deserve protection from vehicles with such extensive and costly problems.