NHTSA Complaint #11694322 — 2022 TESLA MODEL S

Vehicle: 2022 Tesla Model S Tire: Goodyear ElectricDrive 2 255/45R19 104W XL Date of incident: October 15, 2025 Location: Chambers Rd., approximately 1.7 miles from Cosmopolitan Rd., Colorado Speed: Approximately 35 mph (speed limit 40 mph) Mileage on tire: Installed October 31, 2024 — approximately 10,000 miles of light local driving Description of the Problem At approximately 1:30 PM on October 15, 2025, while driving my Tesla Model S southbound on Chambers Road at around 35 mph, the driver-side front tire suddenly exploded and detached completely from the vehicle. I heard a loud thump, then saw a tire rolling ahead of me on the road. The car’s display immediately showed “tire pressure 0.” When I stopped and exited the vehicle, I found that the tire had either blown apart or peeled off the rim and separated entirely from the car. Weather was clear and around 70°F, road conditions were normal, and traffic was light. My tire pressures had been checked earlier that day and were all around 42 PSI. I was unable to retrieve the tire because I have limited mobility and use a scooter. My daughter arrived soon after but could not locate the missing tire either. The vehicle was towed by AAA to a tire shop. The technician stated that the tire appeared to have peeled off the wheel, but could not explain why. The tire was less than one year old and had very low mileage. I drive short local trips daily (around 10–15 miles) and had only taken one 700-mile trip earlier this year. Goodyear was contacted, but they declined to investigate because the tire could not be recovered. This incident could have caused a serious crash had it occurred minutes later on I-25, where I planned to drive at 75 mph. I am reporting this because I believe the tire may have suffered a manufacturing defect, and I am concerned other drivers could experience the same failure.