NHTSA Complaint #11690299 — 2019 VOLVO XC90

UNKNOWN OR OTHER issue reported to NHTSA

Check any vehicle history by VIN - Free vehicle history report

Complaint Details

ODI Number	11690299
Vehicle	2019 VOLVO XC90
Component	UNKNOWN OR OTHER
Date of Incident	August 1, 2025
Date Filed	September 29, 2025
Mileage	N/A miles
Crash	No
Fire	No
Injuries	0
Deaths	0
Vehicle Towed	No
State	KS

Consumer Description

Rear evaporator coil (Failure) The rear evaporator coil failed on my Volvo XC90 purchased new at the dealership in 2019. This car only had 27,000 miles on it when the evaporator coil went bad. Refrigerant smells entered the cabin when AC was on while my 2 year old daughter was in the back. Having refrigerant leaking into the cabin is not great for health, especially that of a toddler. Additionally this could have caused an inability to defrost windows creating a safety hazard. All refrigerant leaked out leading to a condition where I had to drive in 90 - 100 degree temperatures with my daughter.

Related Complaints for the 2019 VOLVO XC90

Other UNKNOWN OR OTHER Complaints

#11712444 — January 21, 2026 — I am writing to formally a repeated mechanical failure involving the HVAC evaporator systems in two Volvo vehicles th...

#11663618 — May 29, 2025 — Vehicle started experiencing stalling and when trying to accelerate it would not pick up on speed, I have been quoted...

#11661326 — May 15, 2025 — Car shut off while driving and rebooted. Was precessed by the infotainment system crashing and then rebooting a minut...

#11629383 — December 7, 2024 — There was a leak on the evaporator coil within the AC system for this car. We started having issues with the AC aroun...

#11621625 — October 23, 2024 — The chrome trim started peeling on the center console, near cup holders. This revealed a razor sharp edge on which I ...

Recent Complaints for the 2019 VOLVO XC90

#11719068 — ENGINE AND ENGINE COOLING — February 19, 2026 — The contact owned a 2019 Volvo XC90. The contact stated that while driving approximately 50-52 MPH, there smoke comin...

#11708339 — ELECTRICAL SYSTEM — January 2, 2026 — Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about ...

#11708339 — ENGINE — January 2, 2026 — Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about ...

#11708339 — STEERING — January 2, 2026 — Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about ...

#11704235 — ELECTRICAL SYSTEM — December 10, 2025 — Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power...