NHTSA Complaint #11665625 — 2018 JEEP WRANGLER

The steering gear box on my Jeep Wrangler has an active technical service bulletin regarding the faulty alluminum steering gear box causing wandering in the steering of the vehicle on all 2018-2020 Jeep Wranglers. This repair is a known issue by FCA as they have a service bulletin regarding the issue. However they have not recalled the defective parts and refuse to cover replacing the defective parts unless the vehicle is still under warranty, or at a substantial cost to me. When I purchased my Jeep from Westgate Jeep in Raleigh, NC in late September 2024 at 84,000 miles the TSB had not been completed by the original owner. The Jeep is lifted but was sold to the original owner in that manner. It is a Rocky Ridge package that was sold the way it still is to the original owner. My safety and the safety of my family is at risk in the vehicle because it wanders excessively in the road. The incident consisted of passing 18 wheeler driving by in the opposite direction causing the Jeep to wander excessively to the right off of the edge of the road causing near loss of control and potential roll over. The issue has been found by my certified mechanic to be related to excessive movement/flexing in the steering gear box. The mechanic drove the vehicle and also noticed the wandering steering. FCA/Jeep should not be allowed to refuse to repair such a significant known issue with vehicles that they manufactured with defective parts they should be held accountable and made to recall and repair those defective parts. There are no active warning lights on the vehicle and a recent alignment was done by a certified mechanic when the tie rod and tie rod ends, drag link and drag link ends, ball joints and steering dampener where replaced. All tires are balanced and have equal wear the steering gear box is the only component of the steering system that has not been replaced and the issue remains. Please reference Mopar T.S.B. 08-074-20 REV. B regarding the known issue. Thank you.