NHTSA Complaint #11648692 — 2012 HYUNDAI SANTA FE

I was contacted by Auffenberg Hyundai in OFallon IL in October of 2024 to schedule recall work. On 10/23/24, the car was dropped off in working condition to the dealership for that recall (engine software update). The day after the vehicle was returned, the check engine light came on and the vehicle went into "limp mode". I returned it to the dealership 10/24/24. They changed the knock sensor and I picked it back up on [XXX]. On the same date, the check engine light came on and vehicle went back into "limp mode". Car was returned to dealership 10/28/24, due to the issue being after hours and on a weekend. They tested it and reset software. I did not get vehicle back until 1/3/25. On [XXX], the check engine light came on again and vehicle went into "limp mode". Car was returned to the dealership and now it is 3/17/25 and I still have no resolution. The vehicle is unsafe to drive because in "limp mode" you cannot go above a certain RPM level. Pulling out into traffic is dangerous when your vehicle just will not accelerate. If this were to happen on the interstate, then it could be catastrophic. The dealership has been able to reproduce this issue, but offers no fix as they state that they are being limited by corporate Hyundai. A corporate claim was made but Hyundai is unwilling to fix an issue they caused. In essence, the recall broke my vehicle and corporate Hyundai has decided to do nothing. Note: All records for repairs and dealership/corporate communications are with Auffenberg Hyundai, 1050 Berg Blvd, Ofallon IL 62269; phone 618-622-9001; contact is John Koch. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)