NHTSA Complaint #11646433 — 2017 FORD EXPLORER

The contact owns a 2017 Ford Explorer. The contact stated that after the battery had been replaced, the vehicle failed to start. The vehicle was jumpstarted several times. The contact stated while driving 60-70 MPH and attempting to overtake another vehicle, the vehicle failed to respond upon depressing the accelerator pedal. The contact returned to the initial lane. The contact stated that the failure recurred several times while driving. The contact stated while the vehicle was parked in front of the residence, the contact noticed that coolant had leaked from the vehicle onto the ground. The contact stated while driving at an undisclosed speed, the engine was overheating. The check engine warning light was illuminated. The vehicle was taken to a Chevrolet dealer, where the contact was informed that there was no coolant in the coolant reservoir and the mechanic determined that the water pump was leaking. The dealer added coolant and water to the vehicle. The contact stated that the engine continued to overheat while driving. The vehicle was taken to Christian Brothers, where it was diagnosed that the water pump and the timing chain needed to be replaced. The vehicle was not repaired due to the cost. The vehicle was towed to an independent mechanic, where the water pump was replaced. The vehicle was towed to another independent mechanic, where the contact was informed that the timing chain and the water pump needed to be replaced at the same time. The vehicle was being repaired. The dealer was notified of the failure. The contact stated that the independent mechanics and the dealer had informed the contact that the failures were common. The manufacturer was notified of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.