NHTSA Complaint #11641440 — 2016 HYUNDAI SANTA FE

This is my 2nd engine on my 2016 Santa Fe Sport. My car has 190,000 miles and had a catastrophic engine failure, it’s been at the dealership for 2 months. Hyundai said my lifetime warranty on my engine is not covered cause I had a misfire in the #4 cylinder with less than 2,000 miles on the spark plugs. Hyundai warranty department only spoke to the dealership directly and had me speak to a case manager (which did nothing, they never even talked to the warranty department only the dealership) So in December I dropped my car off, it took over 2 weeks to take pictures and send them in to Hyundai warranty department, a week later Hyundai asked the dealership to further take the engine apart and get pictures of the rocker’s. The dealership is down to 2 technicians and said they will get to it when they can (remember I’m without a car and waiting for approval for my engine so they can get me in a rental car while my engine gets replaced). Over 3 week later the dealership finally sends the pictures in of the rocker’s, I know cause I called and asked the dealership. I then asked why does the warranty department need pictures of the rockers for my engine failure (misfire in 4th cylinder) and they said to check for sludge. They also pointed out my engine isn’t bad and don’t have sludge so the warranty department should approve my engine replacement. A week later my case manager called and said that they will only approve 50% and I said NO there a lifetime warranty and I’m the original owner, so they went up to 65%. I feel betrayed by the dealership, case manager and Hyundai warranty department for NOT honoring the engine replacement knowing there’s a class action law suit due for failing rod bearings which they said wasn’t the issue. How would they know? The rod bearings are on the bottom of the motor and if they took it apart they would see THAT WAS the cause, but they say they don’t warranty misfire’s yet tens of thousands of Hyundai buyers are having same problems. Help