NHTSA Complaint #11626545 — 2006 CHRYSLER 300

2006 Chrysler 300 Touring 3.5L V6 engine. Car has intermittent stall at slow speeds or at complete stop. Sometimes feels like it stumbles, other times it dies suddenly and unable to tell the engine shut down. I have to put car in park and completely switch the ignition fully off and turn back on to start position. When it stalls while rolling, I have to brake and bring car to full stop, with no power steering, and go through the same start procedure. No trouble codes are generated, and no check engine light indicator illuminated. Car usually starts right up, but sometimes I have to keep cranking starter, stumbles to catch as if starving for fuel. A/C was on first two times but also happens with A/C off. Research online reveals an open recall for the fuel tank on the 300C model with a 5.7L or 6.4L engine. Problems described on the 300C model are nearly identical to what my 300 Touring is experiencing. PCM replacement does not correct problem. Some noticed it happening only with a full tank. Stopgap measure is to only fill no more than 3/4 tank. I am currently testing this idea. The safety issue is significant and twofold; three times I have had one other adult and two children in the car. While stalled at a major intersection traffic signal trying to restart the engine, other vehicles approached from the rear at 50-55 MPH. A rear end collision with children in the back seat would likely be fatal. Secondly, during a stall event while the car is moving, it is extremely difficult to steer the vehicle to a safe place, and braking takes significant pedal pressure once power assist bleeds off. This is a serious concern and obvious collision hazard, as I may not be able to stop or steer to a safe location or avoid a hazard. I had the car at the dealer for over three weeks in July 2024 and they were unable to duplicate the issue. Their answer was to drive car until it happens more frequently. This is unacceptable. No other solution or repair was provided.