NHTSA Complaint #11605241 — 2017 ACURA TLX

Car experiences intermittent electrical system failure. Upon failure, drivers will experiance random and rapid clicking, clanking, and electrical systems discharging like lights, screens, and alarm. After restarting the car, users will find, all warning lights displayed with a few blinking: transmission, parking brake, traction control, a few more. Headlights will randomly turn on, as well as the alarm, intermittently. All ADAS offline. Experienced sudden system failure causing all ADAS to fail while stationary/parked or moving/(actively driving on highway). Does actively affect driving ability more specifically: disrupts steering ability, causes random malfunctions with electrical components, cannot exceed 40 mph, car will not shift above 3rd gear, engine does seem much louder. After a thorough investigation/diagnosis with the dealership I concluded the main fault is due to the "Smart Power Control Unit" located behind the glovebox compartment of the vehicle. More specifically, one of the chips on the circuit board is not fully coated with sealant from the factory, leading to a potential for some kind of mold, dust, or organic growth to form and short one of the ground pins on the end of the chip. Driver States: This is a control unit failure, I believe a small short on a single ground pin with the positively charged chip housing was causing a short within the control unit circuit board where the chip was not fully covered with non-conductive coating/sealant. This caused a handful of issues, like electrical systems prematurely wearing due to rapid discharge of electronics. Impairs drivers ability and ability in turning, braking, and accelerating. Also car will roll backwards if driver is not careful. BIGGEST CONCERNS: FIRE, partial loss of control while driving, and premature wear on electrical components. A extra note: Disconnecting battery does temporarily fix issue but rarely, most time it will start discharging electrical systems immediately or in the day.