NHTSA Complaint #11563502 — 2020 CHEVROLET EQUINOX

Premature headlamp (low beam) failure. The light abruptly failed and it was acknowledged by the manufacturer that this should not have occurred. The failure occurred in October of 2023. Light fixture has since been replaced. The low beam bulb is not accessible for replacement in our vehicle. Instead the entire headlight assembly has to be replaced. The estimated cost for a single replacement was approx $2,600.00. After back and forth with the manufacturer they agreed to replace both headlight assemblies for approximately $1,900.00. A previous recall was issued for GM vehicles in the early 2000s that had similar premature headlight failures. This poses a safety risk because vehicles of this age are likely to still be financed and owners are unlikely to be able to afford a near $3,000 repair for a low beam headlight manufacturing defect. Please note the mileage on the vehicle was roughly 42k. There is the potential that owners will be forced to operate the vehicle with failed headlight(s) while the manufacturer refuses to fully acknowledge it is a manufacturing defect.