NHTSA Complaint #11557397 — 2020 KIA OPTIMA

Oil plug fall out at highway speeds, engine failure. Engine stalled while driving, got vehicle to side of road, called tow truck after attempting to restart. When tow truck driver pulled vehicle onto the flatbed a massive amount of oil came out. After driver towed vehicle home he looked for a hole in the block found where plug had fallen out and advised us to look in the skid plate to see if oil plug was there, if we were lucky we could put it back in, fill with oil and restart. That is when it became obvious that the oil came from drain plug site and oil plug was found. Put plug back in, filled with oil and let the vehicle sit for a while before attempting to restart. Engine would not crank. Had vehicle towed to KIA service center by neighbor and dropped off where it was"lost" for two weeks. After they "found" my vehicle they scheduled a time to look at it. They called needing permission to put in a new starter and told us if they installed the started and the engine failed the test, engine repair would be covered under "this campaign". They put in the starter, ran an engine test and confirmed a new engine was needed. They called later that day, said it was not covered under warranty or campaign. I could not afford the engine replacement so had it towed back home by neighbor after paying for the starter. Car is at home parked and has not been touched since getting it back here. Plug fall out was 4,000 miles after last oil change. Vehicle went into limp mode one time, did need a boost a few times and the day off plug fall out my son was on his way home from work, headed to auto parts store to have them check battery, starter and alternator.