NHTSA Complaint #11555053 — 2015 FORD EXPLORER

The contact owns a 2015 Ford Explorer. The contact stated that the vehicle was repaired under NHTSA Campaign Numbers: 20V675000 (Suspension) and 21V537000 (Suspension) however, after the repairs, the vehicle started experiencing suspension and alignment failures. The contact stated while driving at various speeds, the vehicle seemed misaligned and was pulling to the right and to the left. Additionally, the contact stated that the vehicle shuddered significantly while depressing the brake pedal. The contact also stated that the vehicle was hesitant while depressing the accelerator pedal. The contact stated that while on a road trip, the floorboard of the vehicle was hot, which caused her to pull to the side of the road until the vehicle had cooled down. The vehicle was taken to the dealer several times. The dealer replaced the front brake calipers, rotors and pads, the rear brake rotors, the rack and pinion, the sway bar link, and bushings, the four tires, and performed an alignment several times; however, the failure persisted. The manufacturer was notified of the failure and referred the contact to a second dealer for assistance. The second dealer, Ray Pearman Lincoln (2501 Bob Wallace Ave SW, Huntsville, AL 35805) determined that the recall repairs needed to be performed a second time, and a new set of knuckles needed to be installed. The manufacturer was informed of the second dealer's assessment and referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 89,000.