NHTSA Complaint #11541606 — 2017 KEYSTONE BULLET

1. Component that failed: The leaf springs on the rear axle broke in half. This RV has two rear axles. The leaf springs that broke were both on the rear axle. 2. How was your safety put at risk?: If the springs broke while at highway speeds, control of the Travel Trailer could have been lost. 3. Has the problem been confirmed by a dealer or independent service center?: Yes. Both broken leaf springs have been replaced. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representative?: No. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warnings. We did hear a "pop noise" when one of the springs snapped/broke. The leaf spring broke while making a U-turn. Keystone RV was notified of this spring failure. I wanted Keystone RV to know of this problem in the event other RV Trailer Trailers are experiencing similar suspension failures. I do not overload the travel trailer. The RV Travel Trailer is used primarily in the Rocky Mountain West. So the leaf springs were not subject to salt air and/or high humidity that would lead to corrosion. I drive very conservatively. I am always the slowest vehicle on the highway. I do not camp off-road. The RV Travel Trailer is 6 1/2 years old. The leaf springs should not have failed at such a young age and under the circumstances that exist.