NHTSA Complaint #11539045 — 2015 VOLVO S60

I bought the car as a CPO on 9/25/19 32,860 mi. On 8/19/20 at 50,052 the engine failed. The oscillating dampener rubber separated causing serpentine belt to break, which in turn got caught in timing belt which caused that to break which then caused bent valves and valves to break. The failure was sudden. Had I been on the interstate I’d be severely injured or dead. I was told that I needed a new engine but they could not find one. I was told they would completely re-build my engine. In the end they replaced the cylinder head and starter under warranty. I was never told they didn’t re-build the engine and also used “ good parts” from the old engine. In the following months I had the car in the Volvo shop (Hendricks Volvo Charleston, SC). At 50,277 miles the check engine light showed a problem with the Cam shaft position sensor on 9/3/20. They claim to have driven the car 100 miles and cleared the code w/no repairs. On 3/18/21 w/ 64,485 miles, I took the car into the dealer because it was running and idling rough. They found no codes and they aligned the car. “Couldn’t duplicate”. The right rear door never shut properly and I was repeatedly told it was fine. Re-call on latches. Seat belts on rt rear passenger constantly was stuck. This is where my granddaughter’s car seat was placed. I’ll have to skip some. At 110,024 miles on 11/28/22 the car continued to have bad gas mileage and heavy oil use. I was told that the EGR leak detection pump was faulty and was replaced. At 113,706 miles on 1/19/2023 the cam VVT Solenoid was changed. Cause of poor gas mileage stated. On 3/29/23 at 116,790 miles replaced brakes and had aligned. Service tech noticed oil under the car underside while up on racks. Said it would be fine until next service. On 7/3/23 the engine failed again on the road and was towed to the dealer. Apparently a fuel injector failed causing gas to spray into the engine causing it to lose compression. I’ve never been given a clear answer. Records of services done.