NHTSA Complaint #11498671 — 2005 TOYOTA TUNDRA

The driver's side front frame has rotted out disconnecting the mount for the anti-roll bar. This has happened despite several reports to the dealership going back many years that the frame was rusting rapidly which, upon examination, they said that it was OK. They did apply a coating which might have delayed the process a bit but ultimately resolved nothing. For trucks that had perforated frames during the first few years, they replaced the frame. I tried to take care of mine, but it has finally failed and they say the replacement program is over. They are unwilling to provide even the necessary frame section and mounting bracket for the sway bar (~$545) for the frame shop to install %(2120).This vehicle has less than 98,000 miles on it and is used for short trips performing farmette duties. Frame failure can cause catastrophic accidents and should not be ignored by the manufacturer regardless of age. They know they used bad steel and should act accordingly. My action has been delayed by storm damage to frame shop which didn't reopen until December.