NHTSA Complaint #11466419 — 2007 HYUNDAI VERACRUZ

The contact owns a 2007 Hyundai Veracruz. The contact stated while driving 50 MPH, the vehicle stalled and lost electrical power. Several unknown warning lights were illuminated. The contact was able to veer to the side of the road. The contact was unable to restart the vehicle after several attempts. The vehicle was towed to the dealer where it was diagnosed that engine oil was leaking onto the alternator, causing the alternator and battery to fail. The dealer diagnosed that the alternator, battery, and valve cover gaskets needed to the replaced. Additionally, the dealer diagnosed that the ABS had failed. The alternator and battery were replaced at the owner’s expense. The vehicle was then taken to an independent mechanic for a second opinion on the ABS failure. The independent mechanic advised the contact that the ABS was operating as designed. The manufacturer was notified of the failure and informed the contact that they could not cover the repair of the valve cover gaskets as the vehicle was out of warranty. The contact stated that the failure had been reoccurring while driving. The alternator was replaced several times. The ABS warning light, check engine warning light, and stability control warning light was illuminated. The contact later received NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. A second dealer Lynnes Hyundai (401 Bloomfield Ave, Bloomfield, NJ 07003) was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle also experienced a charging failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 46,000. Parts distribution disconnect.