NHTSA Complaint #11464722 — 2009 CHEVROLET COBALT

Wiring harness is located too close to the human under the driver's seat. Exposes the driver to electrical frequencies that could be avoided if the wire harness was a further distance away from the human. Also, the the fuel line rusted through after 9 years about 9 inches away from the rear axle where the metal tape ends around the fuel line. The metal tape seems to allow more moisture to become trapped around the fuel line; which promotes rust and a leak where the metal tap ends. After the metal tape, the fuel line is in good condition on this specific vehicle. The fuel leak is about 0.5 inches wide and a lot of gasoline drips / leaks after the car is started. The rust particles are located after the fuel filter; which may promote the rust particles to reach the engine via the rusted fuel line. The car has trouble starting (a delay) and needs to have the key turned twice due to the leak. The leak is very close to the muffler, so it seems like it would be at risk of catching on fire if the muffler was hot enough or if it were traveling on a long trip or going up or down a steep hill. The vehicle has been inspected by police. There were no warning lamps or lights.