NHTSA Complaint #11443458 — 2012 FORD FLEX

I am writing you in regards to NHTSA # 20V-072, Ford Recall # 20S04. I own a 2012 Ford Flex. It was not included in this recall. The recall included Ford Flex years 2013 through 2018. Though my SUV wasn’t included in the recall for the defective toe links, my SUV’s toe links were found to be defective on June 1, 2015 at Taylor Ford in Michigan. At that time my vehicle had 56,071 miles on it and was still under warranty. My toe links were replaced with part 5A972 which is the same part that is now the cause of Ford Recall 20S04. On 11-6-21 we took my SUV, with 96,930 miles, into Belle Tire for brake work and tire rotation. At that time we were told that the toe links were defective and needed to be replaced and that my tires were bad and needed replacement too. The tires and toe links had been replaced at Ford 40,859 miles prior! At this point we investigated and found the recall for the toe links. We had never been notified by Ford even though part 5A972 which was later found to be defective, had been put on our SUV in 2015. A Ford Part Employee has confirmed that this part is defective. The defective part is a welded part and the part Ford is using to replace this part is a forged part. Defective toe links are very dangerous. The defect can cause loss of steering/control of SUV. I have contacted multiple levels of Ford Customer Care with no response and no assistance offered. My SUV is currently at a Ford Service Center waiting for Ford to respond so that my SUV can be repaired. I'm unable to drive while waiting because this is very dangerous. It is also very expensive to repair.