NHTSA Complaint #11074949 — 2012 DODGE DART

WHILE DRIVING ON THE INTERSTATE, MY CAR CAUGHT FIRE. I NOTICED MY BATTERY LIGHT COME ON ABOUT 1 MILE FROM MY EXIT AND LESS THAN A MINUTE LATER FLUID SPRAYED ONTO MY WINDSHIELD FROM UNDER MY HOOD. I IMMEDIATELY PULLED OFF TO THE SIDE OF THE INTERSTATE AND AS SOON AS I STOPPED, SMOKE STARTED POURING OUT FROM UNDER MY HOOD. I WALKED AWAY FROM THE CAR AND CALLED 911 AT THAT POINT. DURING THE 911 CALL THERE WAS ONLY SMOKE COMING OUT FROM THE ENGINE BAY AREA. RIGHT NEAR THE END OF THE CALL I STARTED TO SEE PLASTIC THAT WAS ON FIRE DRIPPING BELOW THE CAR ONTO THE GRASS. THE FIRE DEPARTMENT ARRIVED LESS THAN 5 MINUTES LATER AND THE ENTIRE ENGINE BAY WAS IN FLAMES, 10-20 FEET HIGH. THE FIRE MELTED ALL THE PLASTICS AND MOST OF THE METAL OUTSIDE OF THE FRAME AND ENGINE. EVEN THE STEEL HOOD WAS MELTED AWAY AND GONE. MY CAR HAD A LONG HISTORY OF ELECTRICAL ISSUES DATING BACK A LITTLE OVER A YEAR FROM THE TIME OF THE FIRE. DURING THAT TIME, THE ELECTRICAL ISSUES ENCOUNTERED INCLUDED THE DASH BECOMING COMPLETELY UNRESPONSIVE AND NO ELECTRONICS WORKING, THE DASH SCREEN REBOOTING WHILE DRIVING, THE CAR CUTTING OFF WHILE DRIVING, THE SPEEDOMETER AND TACHOMETER NOT WORKING, AND MORE. DURING THE TRIPS TO THE DEALERSHIP, THEY REPLACED THE PCM, BCM (THREE TIMES), AND THE BATTERY. AT ONE POINT, CHRYSLER ENGINEERING WAS INVOLVED AND THEY WERE UNABLE TO DETERMINE WHAT WAS WRONG AND SAID THE CAR LOOKED LIKE IT WAS STRUCK BY LIGHTNING. ENOUGH PARTS WERE FINALLY REPLACED TO FIX THE CAR, TEMPORARILY, BEFORE MORE ISSUES. A COUPLE MONTHS BEFORE THE FIRE I TRIED TO GET CHRYSLER TO BUY THE CAR BACK BECAUSE OF THE ELECTRICAL ISSUES BUT IT WAS DENIED. AFTER THE FIRE, CHRYSLER AND KEFFER BOTH DENIED ANY FAULT ON THEIR PART. YET, I HAVE A THIRD PARTY FIRE REPORT SHOWING THE FIRE WAS ELECTRICAL AND STARTED IN THE AREA OF THE BCM, PCM AND BATTERY. ALL THE PRIOR FAULTED PARTS.