NHTSA Complaint #10649443 — 2005 FORD ESCAPE HYBRID

EARLY SEPT 2014 - BEGAN TO EXPERIENCE INTERMITTENT ISSUES OF "LIMP HOME" MODE. ORIGINALLY, ISSUE BEGAN WITH SMALL "SURGES" IN ACCELERATION THAT I BELIEVED WERE SIMPLY RELATED TO THE HYBRID ENGINE KICKING INTO GEAR. THEN EXPERIENCED MULTIPLE BUT RANDOM "LIMP HOME MODE" EVENTS, PARTICULARLY WHEN STOPPING AT LIGHTS OR ACCELERATING (LIGHT-MOD PRESSURE) FROM A FULL STOP. CAR WOULD FLASH "SERVICE ENGINE SOON" AND NOT GO ABOVE 20MPH AND SOMETIMES NOT THAT. WOULD PULL OFF IF ABLE, OTHERWISE, WOULD HAVE TO STOP WITH FLASHERS IN THE MIDDLE OF THE ROAD, TURN OFF THE ENGINE, WAIT A MINUTE, AND THEN RESTART (REBOOTING CAR). THIS WOULD CLEAR THE CHECK ENGINE LIGHT AND CAR WOULD RESUME NORMAL OPERATION - OF NOTE: CODES WOULD NOT STAY IN THE HISTORY OF THE COMPUTER. AFTER SEVERAL OCCURRENCES, MANAGED TO "LIMP HOME" TO A MECHANIC WHILE THE LIGHT WAS ON AND PULL CODES BETWEEN 2009-2012 AND WAS ADVISED TO HAVE THE COMPUTER REPROGRAMMED BY FORD SERVICE. CAR BEGAN LIMPING HOME DURING FULL TRAFFIC AND FULL ACCELERATION (NOT STOPPED OR SLOWING), CAUSING A MASSIVE SAFETY CONCERN. NOTED MULTIPLE INVESTIGATIVE MENTIONS ON INTERNET REGARDING 2005-2012 ETB ISSUES, BUT ALSO NOTED THIS WAS THEN ONLY "REPLACED" FOR 2009-2012. APPARENTLY, ANYTHING OLDER THAN 09 IS A LOST CAUSE. 10/23/14 - HAVE CAR IN FORD SERVICE AND RECALL (14S19) HAS BEEN NOTED REGARDING MOTOR ELECTRONICS COOLANT PUMP CAUSING "A FAILURE MODE EFFECTS MANAGEMENT STRATEGY THAT CAN RESULT IN A SUDDEN PARTIAL OR FULL LOSS OF MOTIVE POWER" TO PROTECT VEHICLE POWERTRAIN. BEING CHARGED FOR DIAGNOSTIC EVEN THOUGH THERE IS A RECALL ON THE PART THAT IS LIKELY CAUSING THE PROBLEM. *TR