2005 FORD ESCAPE HYBRID — Problems, Recalls & Safety Data

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE VEHICLE STARTED TO OVERHEAT. THE CONTACT PULLED OVER THE SHOULDER OF THE HIGHWAY AND CHECKED UNDER THE HOOD. THE CONTACT FOUND NO DEFECTS UPON INVESTIGATION. DUE TO THE FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO HIS RESIDENCE. THE CONTACT CALLED TOM MASANO FORD LINCOLN (1600 LANCASTER AVE, READING, PA 19607) WHERE HE WAS INFORMED THAT A REPRESENTATIVE WOULD CALL HIM BACK. UPON INVESTIGATION, THE CONTACT LINKED HIS FAILURE TO NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM). THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 121,000.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE OIL CHANGE, THE INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND NOTICED CORROSION ALL AROUND THE FRAME. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 169,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING 35 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT DROVE TO LITHIA FORD LINCOLN OF ROSEBURG (1650 NE STEPHENS ST, ROSEBURG, OR 97470, (541) 537-4643) WHERE IT WAS DIAGNOSED THAT TWO HYBRID FANS NEEDED TO BE REPLACED. THE CONTACT CLAIMED THAT A RECALL WAS ISSUED FOR THIS YEAR, MAKE, AND MODEL VEHICLE; HOWEVER, UPON INVESTIGATION, NO RECALLS COULD BE FOUND. THE MANUFACTURER WAS NOTIFIED AND WERE CURRENTLY ORDERING THE PARTS FOR THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.

OVER THE PAST 3 YEARS I HAVE HAD THE ISSUE OF 'STOP SAFELY NOW' ON MULTIPLE OCCASIONS. THESE ISSUES DIDN'T START UNTIL THE MEC PUMP WAS REPLACED UNDER A RECALL. AFTER THAT MY 2005 ESCAPE HYBRID WILL SHUT DOWN WHILE DRIVING OR NOT START OR CUT OUT THE HYBRID POWER AND RUN ON ENGINE ONLY. I TOOK IT TO THE LOCAL FORD DEALERSHIP WHERE WE HAVE GOTTEN ALL OTHER SERVICE DONE THREE TIMES FOR THESE ISSUES. THEY HAVEN'T BEEN ABLE TO TELL ME ANYTHING, STATING ONLY THAT THERE ARE NO CODES, SO NO IDEA WHERE TO LOOK. I COULDN'T UNDERSTAND HOW THE COMPUTER CAN KNOW TO TELL ME TO STOP DRIVING THE CAR, YET NOT RECORD A DTC. IT HAPPENED AGAIN ON THE FIRST WARM DAY OF THE SUMMER - DROVE ACROSS TOWN, PARKED IT, CAME BACK 20 MINUTES LATER AND IT WOULDN'T START, SHOWING 'STOP SAFELY NOW'. I LEFT IT UNTIL THE NEXT MORNING AND IT STARTED RIGHT UP AND I DROVE IT HOME. I WENT OUT AND BOUGHT SCANXL AND USED MY LAPTOP TO SCAN THE CAR. I FOUND P1A10, P1A14, P0A0A, AND P0A95. IF I CAN BUY SOME CONSUMER PROGRAM AND FIND THIS INFO, WAY IS FORD TELLING THERE ARE NO CODES? FORD ALSO REPLACED THE BATTERY FANS TWO YEARS AGO, STATING THEY WERE COVERED UNDER SOME RECALL OR WARRANTY. SEARCHING THE INTERNET GETS ME 100'S OF COMMENTS ON THIS STOP SAFELY ISSUE WITH DOZENS OF POSSIBLE CAUSES DEPENDING ON THE YEAR AND MODEL. MY SCAN TOOL SHOWS A BATTERY VOLTAGE OF 665 VOLTS, THOUGH IT'S SUPPOSED TO BE A 300 VOLT BATTERY. THE HYBRID EVAPORATOR TEMP CAN RANGE BETWEEN 220 AND 310 DEGREES F WHEN IT'S RUNNING OK. THAT CAN'T BE NORMAL. I HAVE NO IDEA WHAT'S GOING ON AND CAN'T GET ANY HELP FROM THE FORD DEALER.

OVER THE PAST 3 YEARS I HAVE HAD THE ISSUE OF 'STOP SAFELY NOW' ON MULTIPLE OCCASIONS. THESE ISSUES DIDN'T START UNTIL THE MEC PUMP WAS REPLACED UNDER A RECALL. AFTER THAT MY 2005 ESCAPE HYBRID WILL SHUT DOWN WHILE DRIVING OR NOT START OR CUT OUT THE HYBRID POWER AND RUN ON ENGINE ONLY. I TOOK IT TO THE LOCAL FORD DEALERSHIP WHERE WE HAVE GOTTEN ALL OTHER SERVICE DONE THREE TIMES FOR THESE ISSUES. THEY HAVEN'T BEEN ABLE TO TELL ME ANYTHING, STATING ONLY THAT THERE ARE NO CODES, SO NO IDEA WHERE TO LOOK. I COULDN'T UNDERSTAND HOW THE COMPUTER CAN KNOW TO TELL ME TO STOP DRIVING THE CAR, YET NOT RECORD A DTC. IT HAPPENED AGAIN ON THE FIRST WARM DAY OF THE SUMMER - DROVE ACROSS TOWN, PARKED IT, CAME BACK 20 MINUTES LATER AND IT WOULDN'T START, SHOWING 'STOP SAFELY NOW'. I LEFT IT UNTIL THE NEXT MORNING AND IT STARTED RIGHT UP AND I DROVE IT HOME. I WENT OUT AND BOUGHT SCANXL AND USED MY LAPTOP TO SCAN THE CAR. I FOUND P1A10, P1A14, P0A0A, AND P0A95. IF I CAN BUY SOME CONSUMER PROGRAM AND FIND THIS INFO, WAY IS FORD TELLING THERE ARE NO CODES? FORD ALSO REPLACED THE BATTERY FANS TWO YEARS AGO, STATING THEY WERE COVERED UNDER SOME RECALL OR WARRANTY. SEARCHING THE INTERNET GETS ME 100'S OF COMMENTS ON THIS STOP SAFELY ISSUE WITH DOZENS OF POSSIBLE CAUSES DEPENDING ON THE YEAR AND MODEL. MY SCAN TOOL SHOWS A BATTERY VOLTAGE OF 665 VOLTS, THOUGH IT'S SUPPOSED TO BE A 300 VOLT BATTERY. THE HYBRID EVAPORATOR TEMP CAN RANGE BETWEEN 220 AND 310 DEGREES F WHEN IT'S RUNNING OK. THAT CAN'T BE NORMAL. I HAVE NO IDEA WHAT'S GOING ON AND CAN'T GET ANY HELP FROM THE FORD DEALER.