NHTSA Complaint #10496540 — 2010 FORD FUSION

I WAS TRAVELING ON A HIGHWAY GOING APPROXIMATELY 70 MPH AND MY ACCELERATOR BECAME UNRESPONSIVE. THE RPM'S DROPPED TO IDLE, ENGINE DID NOT STOP RUNNING BUT WOULD ONLY COAST. THE WRENCH WARNING LIGHT ICON CAME ON AND LATER THE CHECK ENGINE LIGHT CAME ON. I COASTED TO A STOP AND PUT THE CAR IN PARK WHICH IS WHEN THE CAR BEGAN JERKING. I SHUT THE CAR OFF AND PUT ON MY HAZARD LIGHTS ON THE HIGHWAY. I WAS ABLE TO RESTART THE CAR, BUT IT WAS A ROUGH RESTART. I WAS ABLE TO DRIVE OFF AND IT APPEARED TO RUN FINE. I DID SOME RESEARCH ONLINE AND FOUND THAT MANY OWNERS OF THE FORD FUSION HAVE HAD THIS RECURRING PROBLEM WITH THEIR THROTTLE BODY. THIS ALSO IS AFFECTED BY OTHER MODELS OF 4 CYLINDER ENGINES. MY FORD CUSTOMER SERVICE STATED THAT THEY HAD NO CUSTOMER SERVICE COMPLAINTS ABOUT THIS PROBLEM. I INFORMED THEM OF ALL THE COMPLAINTS ONLINE, THEY TOLD ME THAT THE THROTTLE WAS NOT COVERED BY WARRANTY AND THIS WAS NOT A RECALLED PART. THIS HAPPENED NUMEROUS TIMES AFTER THIS, RESULTING IN TWO NEAR TRAFFIC CRASHES AND ALMOST GETTING TBONED WHILE MAKING A LEFT TURN THROUGH AN INTERSECTION. THE PROBLEM IS THAT THE VEHICLE WILL RUN FINE FOR A DAY OR SAY, BUT WITH NO WARNING STOP RUNNING, SOMETIMES AT THE MOST INCONVENIENT TIMES. I CLEANED THE THROTTLE BODY, BUT IT DID NOT SOLVE THE PROBLEM. I PURCHASED A NEW THROTTLE BODY FROM MY DEALERSHIP FOR $185 WITH TAX AND REPLACED THE PART MYSELF BECAUSE IT WAS VERY SIMPLE. I AM IN NO MEANS A MECHANIC, I AM A COP AND IT TOOK ME ONLY 5 MINUTES TO REPLACE IT. I HOPE FORD IDENTIFIES THIS PROBLEM BEFORE A TRAFFIC CRASH OCCURS DUE TO THE VEHICLE STALLING WITHOUT WARNING. *TR