NHTSA Complaint #10269381 — 2003 NISSAN ALTIMA

I PURCHASED A 2003 NISSAN ALTIMA 2.5L CAR IN JULY OF 2007. THE VEHICLE HAD APPROXIMATELY 51,000 MILES ON IT AND HAD NO ISSUES. APPROXIMATELY 3 WEEKS AGO I WAS DRIVING MY 13 YEAR OLD SON HOME FROM TAE KWON DO AND WAS CROSSING A FREEWAY TO A SIDE STREET WHEN MY CAR BUCKED AND STALLED. LUCKILY I HAD SOME SPEED AND WAS ABLE TO "BARELY" GET THROUGH THE INTERSECTION BEFORE 55+ MPH TRAFFIC SMASHED INTO ME. THE SES LIGHT CAME ON AND I WAS ABLE TO START THE CAR AND MAKE IT HOME AND THEN TO MY MECHANIC THE NEXT DAY. MY MECHANIC INFORMED ME THAT THE CODE READ "CRANKSHAFT POSITION SENSOR". HE REPLACED IT WITH A NISSAN PART, I PICKED UP THE CAR AND THE VEHICLE STALLED JUST BEFORE A VERY HIGH, NARROW, TWO-LANE BRIDGE IN SOLOMONS MARYLAND. I LIMPED BACK TO THE AUTO SHOP AND MY MECHANIC READ THE CODE AND IT SAID "CRANKSHAFT SENSOR" AGAIN. I CALLED NISSAN WHO INFORMED ME I HAD 3 RECALLS ON MY VEHICLE. I TOOK THE VEHICLE TO SHEEHY NISSAN IN WALDORF MD AT 0730. I RECEIVED A CALL FROM THEM AT 1330 AND THEY TOLD ME I NEEDED A NEW ENGINE DUE TO THE PRE-CATALYTIC CONVERTER SUBSTRATE DISINTEGRATING AND BEING INGESTED IN THE ENGINE. AFTER RESEARCHING MY VIN, I DISCOVERED THAT THIS PROBLEM WAS A RECALL THAT WAS COMPLETED ON MY CAR IN 2004. I CONTACTED NISSAN CONSUMER AFFAIRS TO LODGE A COMPLAINT IN THAT A "KNOWN" DEFECTIVE PART FAILED "AFTER" A RECALL AND DAMAGED MY ENGINE AND CAME VERY CLOSE TO CAUSING A POSSIBLY SEVERE ACCIDENT. THEY DENIED MY CLAIM BECAUSE MY CAR WAS AT 82,000 MI. I WAS TOLD THAT IF IT HAPPENED BEFORE 80,000 MI., WHICH I FOUND OUT LATER WAS BECAUSE OF THE FEDERAL EMISSIONS WARRANTY ACT, THEY WOULD HAVE PROBABLY REPLACED THE ENGINE FOR FREE. IT IS MY CONTENTION THAT THE FAILURE OF A PART THAT HAS "NO MAINTENANCE" REQUIREMENTS, THAT HAD BEEN PREVIOUSLY RECALLED BECAUSE OF "KNOWN" DEFICIENCIES SHOULD BE THE RESPONSIBILITY OF THE MANUFACTURER. I ALSO CONTEND THAT THIS DEFECT COULD CAUSE LOSS OF POWER AND CAUSE A SERIOUS ACCIDENT, POSSIBLY RESULTING IN DEATH. *TR