NHTSA Complaint #10252967 — 2004 VOLKSWAGEN PASSAT

ENGINE AND ENGINE COOLING issue reported to NHTSA

Check any vehicle history by VIN - Free vehicle history report

Complaint Details

ODI Number	10252967
Vehicle	2004 VOLKSWAGEN PASSAT
Component	ENGINE AND ENGINE COOLING
Date of Incident	December 27, 2008
Date Filed	December 28, 2008
Mileage	101,000 miles
Crash	No
Fire	No
Injuries	0
Deaths	0
Vehicle Towed	No
State	KY

Consumer Description

IN THE 2004 VW PASSAT TDI (DIESEL ENGINE) THE BALANCE SHAFT & OIL PUMP ARE DRIVEN BY A CHAIN. THE CHAIN FAILED AT 101,000 MILES AND STOPPED ENGINE LUBRICATION INSTANTLY. REQUIRED UNSAFE MANEUVER IN TRAFFIC TO GET OFF ROAD TO A SAFE STOPPING SPOT. *TR

Related Complaints for the 2004 VOLKSWAGEN PASSAT

Other ENGINE AND ENGINE COOLING Complaints

#10627448 — August 22, 2014 — POSSIBLE CAM TENSIONER THAT CAUSES THE CAR TO MAKE A LOUD CLICKING NOISE AND THE CHECK ENGINE LIGHT IS ON AS A RESULT...

#10626953 — August 21, 2014 — I BEGAN NOTICING A VERY STRONG SMELL OF GASOLINE COMING THROUGH THE VENT WHILE DRIVING. WHEN I PULLED OVER TO CHECK U...

#10595853 — June 3, 2014 — TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE VEHICLE STALL...

#10546821 — October 5, 2013 — I WAS DRIVING INSIDE TOWN APPROXIMATELY AT 35 MPH AND WAS STOPPING IN THE STOP LIGHT. WHEN I APPLIED THE BRAKE THE CA...

#10536638 — August 26, 2013 — 2004 VOLKSWAGEN PASSAT. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND UNSATISFACTORY CUSTOMER SERVICE AT DEALERSH...

Recent Complaints for the 2004 VOLKSWAGEN PASSAT

#11677910 — FUEL/PROPULSION SYSTEM — August 1, 2025 — A fuel leak has developed from the top side of the fuel tank on the drivers side of me vehicle. A fuel leak in this m...

#11662869 — FUEL/PROPULSION SYSTEM — May 23, 2025 — There was a recall reported by the manufacturer, Volkswagenm in 2008. There were multiple Fuel System issues: A Heat ...

#11433670 — FUEL SYSTEM, GASOLINE — September 20, 2021 — The contact owns a 2004 Volkswagen Passat. The contact stated that there was gasoline leaking in his driveway where t...

#11396511 — FUEL/PROPULSION SYSTEM — February 16, 2021 — WHEN YOU FILL UP THE FUEL TANK IT LEAKS IT LEAKS A QUARTER OF A TANK OF FUEL ROUGHLY 4 TO 5 GALLONS OF FUEL DRIP OUT ...

#11395719 — SEATS — February 11, 2021 — A COIL FOR HEATED SEATS HAS MELTED A HOLE IN THE DRIVER'S SIDE SEAT. THIS CAUSED PAIN AND CONFUSION WHILE DRIVING ON ...