NHTSA Complaint #10626953 — 2004 VOLKSWAGEN PASSAT

ENGINE AND ENGINE COOLING issue reported to NHTSA

Check any vehicle history by VIN - Free vehicle history report

Complaint Details

ODI Number	10626953
Vehicle	2004 VOLKSWAGEN PASSAT
Component	ENGINE AND ENGINE COOLING
Date of Incident	July 24, 2014
Date Filed	August 21, 2014
Mileage	166,000 miles
Crash	No
Fire	No
Injuries	0
Deaths	0
Vehicle Towed	No
State	VA

Consumer Description

I BEGAN NOTICING A VERY STRONG SMELL OF GASOLINE COMING THROUGH THE VENT WHILE DRIVING. WHEN I PULLED OVER TO CHECK UNDER THE HOOD, I NOTICED THAT THE RIGID FUEL LINE HAD CRACKED WHERE IT PASSED THROUGH A MOUNTING BRACKET ON THE UPPER REAR OF THE ENGINE BAY. THE CRACK WAS EMITTING A STEADY FLOW OF FUEL ONTO THE ENGINE AND EXHAUST MANIFOLD. WE DID NOT DRIVE THE CAR ANY FURTHER AND HAD THE LINE REPAIRED WITH A PATCH OF FLEXIBLE FUEL LINE MATERIAL. *TR

Related Complaints for the 2004 VOLKSWAGEN PASSAT

Other ENGINE AND ENGINE COOLING Complaints

#10627448 — August 22, 2014 — POSSIBLE CAM TENSIONER THAT CAUSES THE CAR TO MAKE A LOUD CLICKING NOISE AND THE CHECK ENGINE LIGHT IS ON AS A RESULT...

#10595853 — June 3, 2014 — TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE VEHICLE STALL...

#10546821 — October 5, 2013 — I WAS DRIVING INSIDE TOWN APPROXIMATELY AT 35 MPH AND WAS STOPPING IN THE STOP LIGHT. WHEN I APPLIED THE BRAKE THE CA...

#10536638 — August 26, 2013 — 2004 VOLKSWAGEN PASSAT. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND UNSATISFACTORY CUSTOMER SERVICE AT DEALERSH...

#10454373 — April 6, 2012 — TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 60 MPH, THERE WAS A COMPLETE LOSS OF ENGIN...

Recent Complaints for the 2004 VOLKSWAGEN PASSAT

#11677910 — FUEL/PROPULSION SYSTEM — August 1, 2025 — A fuel leak has developed from the top side of the fuel tank on the drivers side of me vehicle. A fuel leak in this m...

#11662869 — FUEL/PROPULSION SYSTEM — May 23, 2025 — There was a recall reported by the manufacturer, Volkswagenm in 2008. There were multiple Fuel System issues: A Heat ...

#11433670 — FUEL SYSTEM, GASOLINE — September 20, 2021 — The contact owns a 2004 Volkswagen Passat. The contact stated that there was gasoline leaking in his driveway where t...

#11396511 — FUEL/PROPULSION SYSTEM — February 16, 2021 — WHEN YOU FILL UP THE FUEL TANK IT LEAKS IT LEAKS A QUARTER OF A TANK OF FUEL ROUGHLY 4 TO 5 GALLONS OF FUEL DRIP OUT ...

#11395719 — SEATS — February 11, 2021 — A COIL FOR HEATED SEATS HAS MELTED A HOLE IN THE DRIVER'S SIDE SEAT. THIS CAUSED PAIN AND CONFUSION WHILE DRIVING ON ...