NHTSA Complaint #10249881 — 2004 VOLKSWAGEN PASSAT

ENGINE AND ENGINE COOLING issue reported to NHTSA

Check any vehicle history by VIN - Free vehicle history report

Complaint Details

ODI Number	10249881
Vehicle	2004 VOLKSWAGEN PASSAT
Component	ENGINE AND ENGINE COOLING
Date of Incident	November 23, 2008
Date Filed	November 25, 2008
Mileage	69,800 miles
Crash	No
Fire	No
Injuries	0
Deaths	0
Vehicle Towed	No
State	NY

Consumer Description

ABOUT 1/2 MILE FROM MY HOUSE CAR INDICATED THAT THERE WAS AN OIL PRESSURE ISSUE AND DISPLAYED "STOP ENGINE". PROCEEDED TO DRIVE HOME AND LET THE CAR COOL OFF AND CHECKED OIL LEVEL. OIL LEVEL WAS FINE, BASED ON THE DIP STICK. STARTED THE CAR UP AND THE CAR WAS VERY LOUD AND EXHIBITED A ROUGH AND IRREGULAR IDLE. "STOP ENGINE" INDICATOR CAME ON AGAIN. DID RESEARCH ON THE INTERNET AND FOUND THAT THERE HAVE BEEN NUMEROUS OTHER ISSUES WITH EXACTLY THE SAME ISSUE. ISSUE APPARENTLY SLUDGE BUILD UP IN THE ENGINE. CAR IS CURRENTLY AT REPAIR SHOP AND I HAVE NO FAITH THAT THIS WILL BE RESOLVED IN A POSITIVE WAY (IE NOT COSTING ME AS THE CAR IS OUT OF WARRANTY) AS APPARENTLY THERE IS A DESIGN ISSUE WITH THIS ENGINE AND MANUFACTURER, REPAIR SHOP RECOMMENDED CHANGING THE OIL FILTER AND OIL, YET THE MOST RECENT OIL CHANGE WAS PERFORMED JUST ABOUT 3 WEEKS AGO. NEXT THEY ARE RECOMMENDING THAT THEY TAKE THE OIL PAN OUT AND LOOK FOR "REPAIRABLE CULPRITS", WHICH I BELIEVE IS JUST NONSENSE AS I'M SURE THIS IS NOT THE FIRST TIME THEY'VE DEALT WITH THIS SPECIFIC ISSUE. THIS IS A CASH COW FOR THE REPAIR SHOPS/DEALERS. I WOULD LIKE TO KNOW WHAT IF ANY RECOURSE I HAVE. I'VE SEEN OTHER SIMILAR COMPLAINTS AS WELL, HAS VOLKSWAGEN ACKNOWLEDGED THE ISSUE? I'VE STUCK WITH THE MANUFACTURER'S RECOMMENDED SERVICE INTERVAL AND PRODUCT REQUIREMENTS, SO I AM AT A LOSS IF THIS IS NOT BEING INVESTIGATED AS SOME FORM OF NEGLIGENCE ON VW'S PART. *TR

Related Complaints for the 2004 VOLKSWAGEN PASSAT

Other ENGINE AND ENGINE COOLING Complaints

#10627448 — August 22, 2014 — POSSIBLE CAM TENSIONER THAT CAUSES THE CAR TO MAKE A LOUD CLICKING NOISE AND THE CHECK ENGINE LIGHT IS ON AS A RESULT...

#10626953 — August 21, 2014 — I BEGAN NOTICING A VERY STRONG SMELL OF GASOLINE COMING THROUGH THE VENT WHILE DRIVING. WHEN I PULLED OVER TO CHECK U...

#10595853 — June 3, 2014 — TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE VEHICLE STALL...

#10546821 — October 5, 2013 — I WAS DRIVING INSIDE TOWN APPROXIMATELY AT 35 MPH AND WAS STOPPING IN THE STOP LIGHT. WHEN I APPLIED THE BRAKE THE CA...

#10536638 — August 26, 2013 — 2004 VOLKSWAGEN PASSAT. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND UNSATISFACTORY CUSTOMER SERVICE AT DEALERSH...

Recent Complaints for the 2004 VOLKSWAGEN PASSAT

#11677910 — FUEL/PROPULSION SYSTEM — August 1, 2025 — A fuel leak has developed from the top side of the fuel tank on the drivers side of me vehicle. A fuel leak in this m...

#11662869 — FUEL/PROPULSION SYSTEM — May 23, 2025 — There was a recall reported by the manufacturer, Volkswagenm in 2008. There were multiple Fuel System issues: A Heat ...

#11433670 — FUEL SYSTEM, GASOLINE — September 20, 2021 — The contact owns a 2004 Volkswagen Passat. The contact stated that there was gasoline leaking in his driveway where t...

#11396511 — FUEL/PROPULSION SYSTEM — February 16, 2021 — WHEN YOU FILL UP THE FUEL TANK IT LEAKS IT LEAKS A QUARTER OF A TANK OF FUEL ROUGHLY 4 TO 5 GALLONS OF FUEL DRIP OUT ...

#11395719 — SEATS — February 11, 2021 — A COIL FOR HEATED SEATS HAS MELTED A HOLE IN THE DRIVER'S SIDE SEAT. THIS CAUSED PAIN AND CONFUSION WHILE DRIVING ON ...