NHTSA Complaint #10086131 — 2002 FORD ESCAPE

HAD BEEN HAVING A PROBLEM WITH A LOUD SQUEAKING NOISE COMING FROM THE STEERING COLUMN WHEN TURNING; CHECKED THE NHTSA SERVICE BULLETINS AND FOUND A BULLETIN FROM JUNE 1, 2003 NOTING THIS SAME PROBLEM; CHECK ENGINE LIGHT WAS ALSO ON AGAIN; I MADE AN APPT AT DEALER TO CHECK OUT THESE ISSUES (4/7/04). TOOK VEHICLE IN ON 4/9/04. DEALER FOUND THE FOLLOWING PROBLEMS: NOISE WAS COMING FROM THE UPPER STEERING COLUMN BECAUSE THE WIRING FOR THE HORN WAS PULLED OUT AND RUBBING ON THE CONTACT PLATE; ADDITIONAL NOISE FOUND AT LOWER END OF STEERING COLUMN DEALER DEACTIVATED THE AIRBAG SYSTEM TO REMOVE AND REPLACE THE STEERING WHEEL AND CONTACT; ALSO FOUND THAT THEY HAD TO REPLACE THE STEERING COLUMN BOOT, WHICH HAD TO BE ORDERED AT THE SAME TIME, A RECALL WAS ISSUED FOR THIS VEHICLE REGARDING THE POWER TRAIN CONTROL MODULE; DEALER PERFORMED THE RECALL VEHICLE WAS IN THE SHOP FROM 4/9 - 4/14 AND DEALER HAD TO PAY FOR A RENTAL CAR STEERING COLUMN BOOT WAS ORDERED AND I HAD TO TAKE THE VEHICLE BACK INTO THE DEALER ON 4/23/04 TO HAVE THEM INSTALL IT. AFTER LEAVING THE DEALER ON THE 23RD, I REALIZED THAT MY HORN, CRUISE CONTROL AND LEFT BRAKE LIGHT WERE ALL INOPERABLE, SO I TOOK THE VEHICLE BACK INTO THE DEALER ON 4/26/04. DEALER FOUND THAT THE CLOCK SPRING WAS NOT MAKING CONTACT, SO THEY HAD TO DEACTIVATE THE AIRBAG AGAIN TO REMOVE THE STEERING WHEEL AND REPLACE THE CLOCK SPRING; FOR THE REAR BRAKE LIGHT, THE DEALER HAD TO REPLACE THE BULB ELEMENT VEHICLE WAS IN THE DEALER FOR TWO DAYS AND THEY HAD TO PAY FOR A RENTAL CAR FOR ME AGAIN, *AK