2003 WORKHORSE W22 — Problems, Recalls & Safety Data

The contact owns a 2003 Workhorse W22. The contact stated that upon stopping the motorhome in her driveway, her husband discovered a bluish-black color smoke emitting from underneath the vehicle. The rear passenger side brake caliper had caught fire and the contact's husband was able to extinguish the fire with a water hose. The fire department was not called and a report was not filed. The contact stated that the brake and ABS warning lights had illuminated on the instrument panel after the failure. The contact's husband took pictures of the damage and showed them to an independent mechanic. The mechanic then informed the contact's husband of NHTSA Campaign Number: 09V110000(SERVICE BRAKES, HYDRAULIC) which he linked to the failure. The mechanic contacted then notified the manufacturer of the failure but received no assistance. The contact also made multiple attempts to reach the manufacturer but had no success. The vehicle had yet to be repaired. The failure mileage was approximately 54,000.

NAVISTAR IS RECALLING.....THERE'S A RECALL TO REPLACE ALL FOUR CALIPERS BUT THEY WON'T REPLACE THE ROTORS ALL FOUR OF THEM ARE CRACKED FROM OVERHEATING BECAUSE OF THE CALIPERS HANGING UP . THIS RECALL IS FOR A WORKHORSE W22 CHASSIS.

REAR CALIPERS WERE REPLACED ON RECALL WITH REBUILT CALIPERS. AFTER LESS THAN 500 MILES THE RIGHT REAR CALIPER BLEW OUT ALL BRAKE FLUID RESULTING IN COMPLETE LOSS OF BRAKES. THIS HAPPENED 40 MILES FROM HOME ON A STATE ROAD.

2003 NEWMAR MOUNTAIN AIRE MOTORHOME ON A 2003 WORKHORSE W22 CHASSIS. CONSUMER WRITES IN REGARDS TO WORKHORSE BRAKE SYSTEM RECALL *TGW THE CONSUMER STATED IN MAY OF 2009, HE RECEIVED AN INTERIM NOTICE WARNING ABOUT A POSSIBLE PROBLEM WITH THE WORKHORSE SYSTEM. THE NOTICED STATED THERE WAS A POSSIBILITY OF THE BRAKES STICKING, BURNING AND THE ABS LIGHT ILLUMINATING. IT FURTHER STATED THAT IF THE SYMPTOMS SHOULD APPEAR, THAT THE DRIVER SHOULD PULL OVER AND EXAMINE THE WHEELS FOR EXCESSIVE HEAT AND CONTACT A WORKHORSE SERVICE CENTER. IN JUNE 2009 THE CONSUMER WAS ABOUT 100 MILES INTO HIS TRIP, WHEN HE EXPERIENCED OVER HEATING OF THE BRAKES AND THE ABS LIGHT ILLUMINATED. HE PULLED OVER AND CALLED THE NUMBER LISTED ON THE RECALL. ARRANGEMENTS WERE MADE TO HAVE THE RV TOWED TO A SERVICE CENTER, THE SERVICE CENTER MADE TEMPORARY REPAIRS TO THE RV AND FOUND THERE WAS ALSO A RECALL ON THE CATALYTIC CONVERTER, WHICH WAS ALSO REPLACED. IN JANUARY 2010, THE CONSUMER BEGAN TO NOTICE A SLIGHT LOSS OF POWER AND HE COULD HEAR A MUFFLED SOUND OF BACK FIRING THROUGH THE EXHAUST WHENEVER HE DROVE UP AN UPGRADE AND/OR HARD ACCELERATING. IN JUNE OF 2010, HE RETURNED THE RV TO THE SERVICE CENTER, TO HAVE THEM CHECK THE BACK FIRING AND SEVERAL OTHER ITEMS THAT NEEDED TO BE REPAIRED OR REPLACED, BUT THEY WERE UNABLE TO FIND A PROBLEM. IN OCTOBER 2011, THE RV BEGAN TO SLOW DOWN AND SMOKE STARTED EMITTING OUT OF THE LEFT EXHAUST. THE RV WAS TOWED TO A SERVICE CENTER. A DIAGNOSTIC TEST REVEALED THE CATALYTIC CONVERTERS WERE CLOGGED UP AND BLEW OUT THE MUFFLERS. THE SERVICE CENTER ALSO FOUND THE SPARK PLUGS NEEDED TO BE REPLACED. THE CONSUMER ALSO STATED OVER THE LAST FIVE YEARS, THE FUEL PUMP, SERPENTINE BELT, HEATER VALVE, SPEEDOMETER, DASH PANEL CLUSTER LIGHTS AND TURN SIGNAL/ DIMMER SWITCH ALL HAD TO BE REPLACED. *JB

2003 NEWMAR MOUNTAIN AIRE MOTORHOME ON A 2003 WORKHORSE W22 CHASSIS. CONSUMER WRITES IN REGARDS TO WORKHORSE BRAKE SYSTEM RECALL *TGW THE CONSUMER STATED IN MAY OF 2009, HE RECEIVED AN INTERIM NOTICE WARNING ABOUT A POSSIBLE PROBLEM WITH THE WORKHORSE SYSTEM. THE NOTICED STATED THERE WAS A POSSIBILITY OF THE BRAKES STICKING, BURNING AND THE ABS LIGHT ILLUMINATING. IT FURTHER STATED THAT IF THE SYMPTOMS SHOULD APPEAR, THAT THE DRIVER SHOULD PULL OVER AND EXAMINE THE WHEELS FOR EXCESSIVE HEAT AND CONTACT A WORKHORSE SERVICE CENTER. IN JUNE 2009 THE CONSUMER WAS ABOUT 100 MILES INTO HIS TRIP, WHEN HE EXPERIENCED OVER HEATING OF THE BRAKES AND THE ABS LIGHT ILLUMINATED. HE PULLED OVER AND CALLED THE NUMBER LISTED ON THE RECALL. ARRANGEMENTS WERE MADE TO HAVE THE RV TOWED TO A SERVICE CENTER, THE SERVICE CENTER MADE TEMPORARY REPAIRS TO THE RV AND FOUND THERE WAS ALSO A RECALL ON THE CATALYTIC CONVERTER, WHICH WAS ALSO REPLACED. IN JANUARY 2010, THE CONSUMER BEGAN TO NOTICE A SLIGHT LOSS OF POWER AND HE COULD HEAR A MUFFLED SOUND OF BACK FIRING THROUGH THE EXHAUST WHENEVER HE DROVE UP AN UPGRADE AND/OR HARD ACCELERATING. IN JUNE OF 2010, HE RETURNED THE RV TO THE SERVICE CENTER, TO HAVE THEM CHECK THE BACK FIRING AND SEVERAL OTHER ITEMS THAT NEEDED TO BE REPAIRED OR REPLACED, BUT THEY WERE UNABLE TO FIND A PROBLEM. IN OCTOBER 2011, THE RV BEGAN TO SLOW DOWN AND SMOKE STARTED EMITTING OUT OF THE LEFT EXHAUST. THE RV WAS TOWED TO A SERVICE CENTER. A DIAGNOSTIC TEST REVEALED THE CATALYTIC CONVERTERS WERE CLOGGED UP AND BLEW OUT THE MUFFLERS. THE SERVICE CENTER ALSO FOUND THE SPARK PLUGS NEEDED TO BE REPLACED. THE CONSUMER ALSO STATED OVER THE LAST FIVE YEARS, THE FUEL PUMP, SERPENTINE BELT, HEATER VALVE, SPEEDOMETER, DASH PANEL CLUSTER LIGHTS AND TURN SIGNAL/ DIMMER SWITCH ALL HAD TO BE REPLACED. *JB