2002 WORKHORSE W22 Engine And Engine Cooling Problems

2002 WORKHORSE CHASSIS DOLPHIN MOTORHOME. CONSUMER STATES PROBLEMS WITH THE ENGINE STALLING *TGW THE CONSUMER STATED THE RV HAS BEEN REPEATEDLY TOWED, SERVICED AND EVEN REPAIRED ONLY TO ENCOUNTER THE SAME PROBLEM. THE ENGINE WOULD SUDDENLY STALL WITH NO WARNING. WITHIN A PERIOD OF 10 SECONDS, THE POWER BRAKES AND STEERING BECAME UNRELIABLE AND THE ACCELERATOR WENT TO THE FLOOR. *JB

2002 BOUNDER WITH CHEVY WORKHORSE CHASSIS BRAKE SYSTEM FAILURE. *NJ THE CONSUMER WAS INFORMED THE FRONT CALIPER ON THE PASSENGER SIDE HAD SEIZED AND DESTROYED ALL THE PREVIOUS BRAKE WORK THE CONSUMER HAD DONE 56 MILES AGO. THE LEFT FRONT OIL SEAL WAS LEAKING. *JB

WHILE DRIVING DOWN THE ROAD, THE ENGINE JUST SHUTS DOWN. THIS HAPPENS AT ANYWHERE FROM 2 TO 10 MILES AFTER STARTING DOWN THE HIGHWAY. THIS HAS HAPPENED A TOTAL OF FOUR TIMES TO ME. IT ACTED AS IF THE IGNITION IS TURNED OFF. UPON THE SECOND SHUT DOWN, A SCAN TOOL WAS USED AND PRODUCED THE CODE INDICATING THERE WAS A MALFUNCTION IN THE CRANKSHAFT POSITION SENSOR. AFTER PULLING OFF THE ROAD AND ALLOWING THE ENGINE TO SIT FOR ABOUT 30 SECONDS THE ENGINE CAN BE RESTARTED AND DRIVEN FOR AS FAR AS 125 MILES WITH NO FURTHER PROBLEM. EACH AND EVERY TIME SINCE THE INITIAL START OF THE PROBLEM, THE PROBLEM HAS OCCURRED EACH TIME THE VEHICLE WAS DRIVEN. THIS ENGINE IS A 8.1 L CHEVROLET ENGINE INSTALLED IN A 2002 RV WITH A CHASSIS BUILD DATE OF 9/28/01. ALL OF THE SYMPTOMS ARE EXACTLY AS NOTED IN THE...

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 TRAILER. WHEN THE CONTACT EXITED THE VEHICLE, HE SMELLED THE BRAKES AND WHEEL BEARINGS BURNING. THE CONTACT REMOVED THE WHEEL AND NOTICED OIL FROM THE WHEEL BEARING COVERING THE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED. IN OCTOBER OF 2007, THE CONTACT SMELLED AN ODOR COMING FROM THE REAR BRAKES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DUPLICATE THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 16,000. UPDATED 04/22/08. *LJ THE CONSUMER WAS TOLD THE REAR BRAKES WOULD NOT BE REPLACED WITH UPGRADED BRAKES. THE CONSUMER STATED THE PROBLEM STILL EXISTS WITH THE BRAKES. THE CHECK ENGINE LIGHT ILLUMINATED. THE CRUISE CONTROL DID NOT COME. UPDATED