2006 VOLVO S40 Fuelpropulsion System Problems

Check engine light came on and stays in. Vehicle always sputters to start, acceleration is sometimes slow to respond, has stalled out on a rare occasion usual on hills. I’m afraid someday I might be involved in a crash because of a lack of acceleration.

Check engine light came on and has stayed on. Stalled out in traffic, turned the car off and it restarted and I continued. Happens two more times. Initial start up has a delay in the engine turning over. Gas pedal is slow to respond to acceleration. Verified at a garage with code reader. Suspect faulty wiring (corrosion) to fuel pump needing PEM replacement. No warning prior to first incident around 02/2022. I have had the check engine light reset on multiple occasions and each time the light comes back on within 2 days. Safety has been a concern at multiple times. Entered VIN number with Volvo, a Volvo dealer, and nhtsa.gov with no help in resolving issue.

IN SOME OCCASIONS CAR WON'T START AND WHILE DRIVING THE CAR IT WOULD SHUT OFF UNEXPECTEDLY CAUSING A DANGEROUS SITUATION. I BELIEVE IT'S THE PUMP ELECTRONIC MODULE WHICH IS ALREADY RECALLED IN SOME CARS. ACCORDING TO YOUR RECALL I HAVE THE EXACT SAME SYMPTOMS BUT MY VIN NUMBER IS NOT PART OF THE RECALL.

I WENT OUT TO START MY CAR FOR WORK AND IT WOULD NOT START LIKE IT WAS OUT OF BUT I HAVE A HALF TANK OF GAS IN IT BUT FOR SOME REASON IT SOUNDS LIKE THE FUEL PUMP/MODULE IS NOT WORKING.

RECALL ON- FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP VOVLVO RECALL NO. 190

TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE ENGINE STALLED WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT FUEL FUMES WERE PRESENT AROUND THE VEHICLE, BUT NO FUEL LEAKS COULD BE FOUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.