1990 VOLVO 780 — Problems, Recalls & Safety Data
N/A
Safety Rating
1
Owner Complaint
2
Recalls
1
Service Bulletin
0
Investigations
Overview of the 1990 VOLVO 780
The 1990 VOLVO 780 has received a total of 1 safety complaint filed with the National Highway Traffic Safety Administration (NHTSA). There have been 2 recall campaigns affecting this vehicle, covering issues with ELECTRICAL SYSTEM:WIRING, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. 1 technical service bulletin have been issued by Volvo Car USA, LLC for this model year. The most commonly reported problem area is the Seatsfront Assemblyseat Heatercooler (1 complaint).
Recalls for the 1990 VOLVO 780
NHTSA has recorded 2 recalls for the 1990 VOLVO 780, potentially affecting up to 28,970 vehicles.
Recall 97V166000 — ELECTRICAL SYSTEM:WIRING
| 9,684 vehicles affected
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO LIMITED SPACE AND VARIATIONS IN THE ASSEMBLY OF THE CABLES, CHAFING OF THE INSULATION OF THE CABLES FEEDING THE SEAT HEATER, POWER SEAT MOTORS AND SEAT BELT WARNING INDICATOR SITUATED UNDER THE FRONT SEAT, CAN OCCUR.
Consequence: THIS CHAFING CAN LEAD TO A LOW OHM SHORT CIRCUIT.
Remedy: DEALERS WILL INSPECT THE CABLE HARNESSES AND, IF NECESSARY, CORRECT OR REPLACE THESE CABLES.
View full details →Recall 91V010000 — FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
| 19,286 vehicles affected
Defect: IF CONDITIONS OF HIGH AMBIENT TEMPERATURE, OVERFILLING OF THE FUEL TANK, AND INSUFFICIENT TORQUE ON THE SENDING UNIT LOCK RING EXIST SIMULTANEOUSLY, FUEL SEEPAGE MAY OCCUR FROM THE TOP OF THE TANK.
Consequence: FUEL SEEPAGE COULD RESULT IN FIRE IN THE PRESENCE OF ANIGNITION SOURCE.
Remedy: RETORQUE SENDING UNIT LOCK RING; REPLACE LOCK RING GASKET IF FUEL SEEPAGE IS DETECTED. NOTE: THE ONLY 940 MODEL SUBJECT TO THIS RECALL IS THE 940SE.
View full details →Owner Complaints for the 1990 VOLVO 780
1 complaint has been filed with NHTSA for the 1990 VOLVO 780. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Seatsfront Assemblyseat Heatercooler | 1 | 0 | 1 | 0 | 0 |
Most Recent Complaints
SEAT HEATER SHORTED OUT, CAUSING FIRE .
Safety Rating for the 1990 VOLVO 780
NHTSA has not yet tested the 1990 VOLVO 780 in its New Car Assessment Program.
Technical Service Bulletins for the 1990 VOLVO 780
Volvo Car USA, LLC has issued 1 technical service bulletin (TSBs) for the 1990 VOLVO 780. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
GRP87/930 — VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
REPLACEMENT OF BLOWER MOTOR. *TW
NHTSA Investigations for the 1990 VOLVO 780
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the VOLVO 780
- 1987 VOLVO 780 — 2 complaints
- 1988 VOLVO 780 — 5 complaints
- 1989 VOLVO 780 — 4 complaints
- 1990 VOLVO 780 (current)
- 1991 VOLVO 780 — 3 complaints
- 1992 VOLVO 780 — 0 complaints
Other VOLVO Models
- VOLVO XC90 — 2,131 total complaints
- VOLVO S60 — 1,655 total complaints
- VOLVO S80 — 1,320 total complaints
- VOLVO V70 — 1,177 total complaints
- VOLVO XC60 — 846 total complaints
- VOLVO S70 — 780 total complaints
- VOLVO 850 — 732 total complaints
- VOLVO S40 — 677 total complaints