2022 VOLKSWAGEN PASSAT — Problems, Recalls & Safety Data

Manufacturers defect. Known excessive oil consumption of the 2.0 Turbo 4 cylinder engine.

In May of 2023, I reported that the driver side rear brake caliper appeared to be sticking as one pad at that corner was completely worn down and making contact with the rotor, while the other pad at that same corner had no visible wear. Dealer replaced the rear left rotor under warranty (40,805 miles). Warranty also covered both rear rotors and rear pads due to rotor damage. In February of 2024, dealer inspection noticed the exact same issue on rear right brake caliper and replaced it under the extended warranty (59,631 miles). Although rear right rotor was damaged again, the extended warranty did NOT cover rear rotors or pads and I had to cover the cost out of pocket. In November of 2024 with approximately 80,000 miles, I performed a full brake inspection and noticed that even at this mileage, there was NO visible wear to the factory installed front brake pads (which at this mileage was odd and concerning), and while inspecting the rear pads I noticed that there was no visible wear to the rear left pads, but the rear right pads were worn down almost to the rotor. This uneven wear was shown to the dealer and after a day of "diagnosis", the dealer tech found no issues. They claimed fluid was flowing freely and the brake pistons were not sticking (pointing to the ABS module applying significantly more braking force to the rear right corner, in my opinion). I pressed the issue and after another day of diagnosis, they claimed the ABS module was defective and submitted the claim to the extended warranty. Claim was approved and part is no order, but I do not trust the braking system on this car with brake pads wearing unevenly down to the rotors every 20,000 miles and no perceivable braking force taking place on the front brakes. I, again will have to cover the costs to replace the rear pads and rotors due to continued related and warrantied part failures. I also raised the issue to VW Customer CARE, who created a case and is investigating with the dealer.

While driving car began to jerk and had odd smell. Stopped at a Midas to have car looked at and all of the transmission fluid leaked out. Techs at Midas state the gasket that hold the fluid in came out and caused all the fluid to leak out. Had no issues while driving previous to this, this just happened randomly in the middle of our drive. We did jot hit or run over anything and the road we were traveling on was in good paved condition.

I keep adding oil and the dealership says there’s nothing wrong. For electric problems the speakers have static noise and the screen goes black and turns on hours later. I took in my recently they said there wasn’t any problems with the car but I literally deal with it everyday. I told them my car shakes when I brake on high speed they said they checked car but found no issues I personally do not feel safe driving my car at all.

I keep adding oil and the dealership says there’s nothing wrong. For electric problems the speakers have static noise and the screen goes black and turns on hours later. I took in my recently they said there wasn’t any problems with the car but I literally deal with it everyday. I told them my car shakes when I brake on high speed they said they checked car but found no issues I personally do not feel safe driving my car at all.