2007 VOLKSWAGEN PASSAT Engine And Engine Cooling Problems

I WAS DRIVING THE CAR WHEN THE ENGINE FAILED WITHOUT ANY WARNING AND WITHOUT ANY DASHBOARD INSTRUMENTS INDICATING IMPENDING FAILURE. ME AND MY CO-PASSENGER ARE LUCKY TO BE ALIVE TODAY. FURTHER WE ARE LUCKY WE DIDN'T CRASH INTO A PUBLIC BUS PULLING IN AT THE BUS STOP AS WE VEERED TO THE RIGHT TO BRAKE AND PARK THE VEHICLE. THIS CAR HAS BEEN METICULOUSLY MAINTAINED AT THE DEALERSHIP SINCE ITS ACQUISITION AND AT THE 65,000 SERVICE IT WAS GIVEN AN EXCELLENT BILL OF HEALTH. WHEN THE CAR WAS TOWED TO THE DEALERSHIP FOR REPAIRS IT WAS DIAGNOSED AS UNUSUAL ENGINE FAILURE.

I HAVE EXPERIENCED AN ENGINE HESITATION (OR MISFIRE ISSUE ACCORDING TO THE DEALERSHIP) AND LOSS OF POWER AS DESCRIBED IN NHTSA ACTION # EA11002. THE DEALERSHIP REPLACED THE SPARK PLUGS TO TRY AND CORRECT THE ENGINE FAULTS.

FALSE EPC AND CHECK ENGINE LIGHTS. WHEN CHECKED BY DEALER, THEY STATED THERE WAS NOTHING WRONG AND ONLY SOFTWARE UPDATE WAS NEEDED. I WAS CONCERNED THAT THERE WAS A SOFTWARE GLITCH THAT WILL AFFECT THE CORRECT FUNCTIONING OF THE VEHICLE.

ELECTRICAL PROBLEMS FROM DAY ONE - CONSTANTLY A NEW LIGHT ON THAT NEVER STAYED ON. DRIVER'S AIRBAG ISSUE THAT VW SAYS IS AN ELECTRICAL PROBLEM UNDER THE DRIVER'S SEAT - A FEW HUNDRED DOLLARS TO FIX A FEW MONTHS AGO, THE CHECK ENGINE LIGHT CAME ON AND VW CHARGED US TO RUN A DIAGNOSTIC TEST THAT CAME BACK WITH 12 FAILURE CODES, THE TWO MOST SEVERE BEING INTAKE RUNNER MOTOR AND HIGH PRESSURE PUMP. THEN, NOT LONG AFTER, THE CAR LITERALLY SHUT DOWN ON THE HIGHWAY AND WE COULD HARDLY GET TO THE SIDE OF THE ROAD (MIND YOU NO PRIOR WARNING LIGHTS WERE PRESENT). THE ONLY ONE THAT CAME ON FOR A SPLIT SECOND WAS THE EPC (ELECTRONIC POWER CONTROL) LIGHT BEFORE THE CAR SHUT OFF. THE VEHICLE HAD TO BE TOWED TO VW DEALER WHO AFTER INVESTIGATING THE PROBLEM, SAID THAT THE ENGINE WAS SHOT. AND, I ALMOST...

MY WIFE WAS DRIVING ALONE IN OUR 2007 VOLKSWAGEN PASSAT WITH THE 3.6 LITER ENGINE ON A REMOTE, LONELY RURAL ROAD WHEN THE "CHECK ENGINE AND OIL" LIGHTS ILLUMINATED. SHE PULLED OFF THE ROAD AS SOON AS POSSIBLE BUT WAS FRIGHTENED AT BEING ALONE AND STRANDED ON A REMOTE ROAD. FORTUNATELY A TEXAS STATE TROOPER DROVE BY, STOPPED AND CALLED A TOW TRUCK FROM THE NEAREST TOWN. THE VEHICLE WAS TOWED TO A VW DEALERSHIP. THE ENGINE WAS DECLARED A TOTAL LOSS, APPARENTLY DUE TO LOSS OF OIL PRESSURE. AN ESTIMATE OF $12,000 WAS QUOTED TO ME FOR REPLACING THE ENGINE. VOLKSWAGEN OF AMERICA REFUSED TO AUTHORIZE REPAIRS UNDER THE 60,000 MILE POWER TRAIN WARRANTY IN SPITE OF THE NUMEROUS COMPLAINTS REGISTERED ON LINE FOR THIS EXACT SAME PROBLEM WITH THIS EXACT SAME YEAR, MAKE, MODEL AND ENGINE INCLUDING NHTSA ODI NUMBERS 10229007, 10203527, 10203183 AND 10193036 AND ADDITIONAL NUMEROUS...

VEHICLE LOW OIL PRESSURE ALARM CAME& STOP ENGINE ALARM, I STOPPED VEHICLE, NO OIL ON DIPSTICK, I PUT IN 4 QTS, OIL, STILL NOT FULL, TOOK TO DEALER, THEY SAID IT NEEDS PISTON RINGS, I ASKED ABOUT THE TURBO & INTERNAL PARTS POSSIBLY DAMAGED DUE TO OIL STARVATION, THEY WILL ONLY REPLACE RINGS, IF ANYTHING ELSE FAILS AFTER THE REPAIRS THEY WILL REPAIR IT AS LONG AS IT IS STILL UNDER FACTORY WARRANTY, THE VEHICLE HAS APPROX 13000 MILES, I REQUESTED A NEW ENGINE SINCE THE VEHICLE IS NEW, NO HELP FROM CUSTOMER SERVICE OR DEALER, I AM AFRAID I WILL HAVE TO REPLACE THE ENGINE AFTER THE WARRANTY EXPIRES DUE TO SOME INTERNAL PARTS PREMATURE WEAR DUE TO THE OIL CONSUMPTION WHICH WAS CONFIRMED BY VW DEALER, APPROX 1.9 QUARTS IN 662 MILES. *TR

2007 VOLKSWAGEN PASSAT. ENGINE STARTED KNOCKING SO I HAD IT TOWED TO THE DEALER. IT ENDED UP NEEDING A NEW ENGINE BECAUSE THE HIGH PRESSURE FUEL PUMP PLUNGER FAILED AND SENT METAL INTO THE ENGINE DESTROYING IT. VW REFUSES TO PAY FOR IT. *TR

A BOLT IN THE OIL PUMP FAILED CAUSING LOSS OF OIL PRESSURE ON HIGHWAY. ENGINE SHUT OFF AT SPEED IN MODERATE TRAFFIC. *TR

TL*THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT. WHILE APPROACHING A STOP, THE ENGINE BEGAN TO REV AND THE RPM NEEDLE INCREASED. THE VEHICLE WAS IN DRIVE AND THE BRAKE PEDAL WAS DEPRESSED AT THE TIME. THE CONTACT PLACED THE VEHICLE INTO PARK AND TURNED OFF THE ENGINE. WHEN HE RESTARTED THE VEHICLE, IT SEEMED TO OPERATE NORMALLY. AFTER A FEW DAYS, THE FAILURE RECURRED. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS DUE TO A RECALL ON THE ENGINE FOR UNINTENDED ACCELERATION. THE VEHICLE WAS REPAIRED, BUT THE CONTACT WAS UNSURE OF WHAT WAS ACTUALLY REPAIRED. THREE WEEKS AFTER THE REPAIRS WERE MADE, THE FAILURE RECURRED, THE VEHICLE JERKED FORWARD AND CRASHED INTO THE BUMPER OF THE PRECEDING VEHICLE. THE DEALER WAS NOTIFIED AND THE VEHICLE HAS REMAINED THERE EVER SINCE. NO REPAIRS HAVE BEEN MADE YET BECAUSE THE DIAGNOSTIC RESULTS INDICATE THAT NOTHING IS WRONG WITH THE...

ON START-UP, ENGINE TROUBLE LAMP COMES ON, SOMETIMES STEADY SOMETIMES BLINKING. IF BLINKING, VEHICLE MISFIRES, ENGINES SHAKES VIOLENTLY. SUBMITTED TO VW, INC.-OWNED DEALERSHIP REPAIR FACILITY ON 4 OCCASIONS FOR SAME PROBLEM. VEHICLE HAS BEEN IN REPAIR FACILITY FOR 15 OF THE LAST 30 DAYS. VEHICLE PURCHASED 01/2007 AND TO DATE HAS BEEN DRIVEN 6,500 MILES. DEALER REPAIR REP SAYS VW CANNOT IDENTIFY SOURCE OF PROBLEM, AND HAS NO IDEA WHEN THE REPAIR WILL BE COMPLETED. DEALER DENIES THAT ANY TSB HAS ISSUED. *TR

MY 2007 VW PASSAT WAGON HAS 3 TIMES ON TRIPS LONGER THAN 4 HOURS IN 0 DEGREE WEATHER STARTED CHUGGING AND SHAKING ON THE HIGHWAY. EACH TIME HAS BEEN WORSE AND LASTED LONGER. THE FIRST TIME A CALL TO A VW DEALER SAID IT WAS THE GAS CAP AND IT WOULD BE OK. THE SECOND TIME A SUBARU MECHANIC DIAGNOSED MISFIRING AND A BAD COIL SO I TOOK IT TO A VW DEALER WHO SAID THERE WAS NOTHING THEY COULD FIND WRONG TO FIX. THE THIRD TIME I WAS NEARLY STRANDED ON A REMOTE HIGHWAY. I EVENTUALLY GOT HOME TO MY PRIVATE MECHANIC WHO AGREED IT WAS MISFIRING AND A BAD COIL AND WILL FIX IT. *TR

WHEN DECELERATING TO A STOP, THE ENGINE REVS MORE THAN NORMAL. THE FAILURE OCCURS INTERMITTENTLY. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE IS 4800 AND IT HAPPENED AT 4780. *TR

COMPLAINT INVOLVES AN ENGINE FAILURE I HAD ON MY 2007 VOLKSWAGEN PASSAT WAGON 3.6L. THE PROBLEM STEMS FROM A FAULTY "OIL PUMP BOLT/CAM BOLT" . THIS PROBLEM HAS BEEN CITED WITH NUMEROUS 3.6L VW OWNERS AND MORE INFORMATION CAN BE FOUND ON THE VW SPONSORED VWVORTEX WEBSITE. I AM FILING THIS COMPLAINT BECAUSE OF THE POTENTIAL FOR FIRE OR PERSONAL INJURY. VW NEEDS TO RECALL THESE VEHICLES AND REPLACE THE FAULTY BOLT BEFORE OWNERS WARRANTIES EXPIRE RESULTING IN COSTLY REPAIRS (TO REPAIR THIS PROBLEM THE ENGINE NEEDS TO BE REMOVED). HTTP://FORUMS.VWVORTEX.COM/ZEROTHREAD?ID=3193697 HTTP://FORUMS.VWVORTEX.COM/ZEROTHREAD?ID=3448589 THANK YOU FOR YOUR ATTENTION TO THIS MATTER. *JB

TL*THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT WAGON. WHILE DRIVING APPROXIMATELY 65 MPH, THE CHECK ENGINE AND OIL LIGHTS ILLUMINATED. THE CONTACT PULLED OVER AND NOTICED BLUE SMOKE COMING OUT OF THE EXHAUST. HE SHUT THE VEHICLE OFF AND ATTEMPTED TO RESTART IT, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THERE WAS CATASTROPHIC ENGINE FAILURE DUE TO THE DEFECT NUTS FROM THE OIL PUMP. THE DEALER REPLACED THE ENTIRE ENGINE. THE VIN, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE FAILURE MILEAGE WAS 23,000 AND CURRENT MILEAGE WAS 25,000.

COMPLETE/CATASTROPHIC ENGINE FAILURE AT APPROX 1,800 MILES. DEALER STATED BOLT RELATING TO TIMING CHAIN FAILED, CAUSING SERIOUS INTERNAL ENGINE DAMAGE. VEHICHLE WAS REPLACED, BUT NEW VEHICLE HAS SAME ENGINE, AND MANY OTHERS WITH SAME ENGINE ARE HAVING SIMILAR FAILURES.

NO THROTTLE RESPONSE, LONG ACCELERATOR PEDAL REPSONSE FROM A STANDING START OR ROLLING START. TRYING TO MOVE INTO TRAFFIC IS DANGEROUS, PRESS ON THE PEDAL EVEN FLOOR IT AND NOTHING HAPPENS, STUCK IN THE MIDDLE OF AN INTERSECTION COMING INTO TRAFFIC, THEN EVENTUALLY, ALL 280 HP COME ON AND THE CAR ALMOST GETS OUT OF CONTROL IF TURNING. THIS HAPPENS ALL THE TIME. THIS IS A NEW CAR, I HAVE HAD THE CAR SINCE 4/14/07 AND FINALLY TAKING IT TO THE DEALER NEXT WEEK TO SEE WHAT THEY CAN DO. *TR