2006 VOLKSWAGEN JETTA Engine Problems

So it appears to be fine until about 30/45 mins drive time Then it starts shifting/slamming real hard and hesitates to shift in the next gear To the point where stopping and going isn’t an option or it slips After about 45 mins all the prnds lights turned on and did the same in manual mode.. I read someone it’s a valve body that leads to a faulty Tranny I’ve read almost 150 of the same exact accounts on here and Reddit With the same 2006 Vw Jetta 2.5 It’s too common of an issue Most of them were under 100k miles and never dealt with by the manufacturer Myself my car has roughly 168k miles and I’ve been working to fix it up I just got it a month or so ago And now I have to deal with this Honestly is sad that VW hasn’t been held accountable...

The windshield wiper broke the window, brakes need replaced to soon, fuel system car has trouble fueling and after fueling and engine over heating due to engine cooling malfunction. None of these have been repaired yet it shows 0 unprepared recalls.

THERE ARE SOME MOUNTING BRACKETS, SUSPENSION BRACKETS, NUTS AND BOLTS ASSOCIATED TO THE OPERATION OF THE VEHICLE THAT HAVE BROKE MORE THAN ONCE PLEASE CONTACT ME AND I WILL GIVE U FURTHER DETAIL.[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).. *TR

THE VEHICLE HAS A LONG HISTORY OF THE THROTTLE BECOMING INOPERATIVE RESULTING IN NO-POWER (IDLE POWER STRICTLY SPEAKING) CONDITIONS. THAT CONDITION IS CLEARED WHEN THE CLUTCH PEDAL IS DEPRESSED AND RELEASED. RECENTLY THERE WAS AN INSTANCE OF UNCOMMANDED ACCELERATION: INSTEAD OF NO POWER, FULL POWER WAS APPLIED BY THE ENGINE. AGAIN CYCLING THE CLUTCH CLEARED THE CONDITION. THE NO-POWER CASES APPEARED MORE LIKELY IN URBAN DRIVING AND SOON AFTER A TRANSMISSION SHIFT BUT DID OCCUR UNDER ALMOST ANY CONDITIONS. THE FULL-POWER CASE OCCURRED ONCE, CLIMBING A HILL AT ~2800' ALTITUDE. THE POWER FAIL OCCURRED AS EARLY AS 34K MILES, AND CONTINUED WITH VW'S KNOWLEDGE UNTIL ~72K MILES, WHEN VW OF AMERICA TECHNICIANS FINALLY DID SOMETHING TO END IT. THOSE SYMPTOMS STARTED RECURRING AT ~270K MILES. THE ACCELERATION INCIDENT OCCURRED AT ABOUT 275K MILES. THE VEHICLE HAS BEEN TAKEN OUT OF SERVICE; IT WILL BE SENT TO A SALVAGE YARD IF...

KEY GETS STUCK IN IGNITION WHEN TURNING OFF THE ENGINE.

MY CAR HAS SOME SHIFTING PROBLEMS WHEN IN MOTION.MY CAR HAS A JERKING MOTION THAT IT DOES WHEN GOING INTO GEARS AND WHEN SLOWING DOWN ITS ROUGH GOING DOWN GEARS.

MY CAMSHAFT AND LIFTERS WENT BAD AND WERE REPLACED IN 2015. IT WAS JUST AROUND 100,000 MILES. THEN I FOUND OUT TODAY THAT THEY WERE BAD AGAIN. MY UNDERSTANDING FROM THE MECHANIC IS THAT THIS IS A COMMON PROBLEM, AND LOOKING AT THE VOLKSWAGEN TDI FORUM, THAT YEAR IS PARTICULARLY BAD. THIS CAMSHAFT FAILURE CAUSED A LOSS OF POWER ON THE INTERSTATE DURING A HEAVY TRAFFIC TIME, BOTH TIMES. FIRST INCIDENT WAS ON I-240 IN ASHEVILLE MIDDAY. SECOND TIME WAS TRAVELLING WEST ON I-40 NEAR MORGANTON, NC IN EVENING TRAFFIC. LOSS OF POWER, SMOKING. I COULD BARELY GET OFF THE EXIT. I WAS LUCKY NOT TO HAVE IMPEDED TRAFFIC, BOTH TIMES.

WHILE DRIVING ON THE INTERSTATE JULY OF 2015, GOING ABOUT 70 MPH, MY 2006 VW JETTA SHOOK AND LOST ALL POWER. NO CHECK ENGINE LIGHTS OR ANY LIGHTS AT THAT MATTER CAME ON. PRIOR TO THIS I WOULD NOTICE THAT TAKING OFF SOMETIMES THE TURBO WOULDNT KICK IN AND I WOULD HAVE ABSOLUTELY NO POWER WHILE GETTING UP TO SPEED. THIS ALSO HAPPENED ON THE FREEWAY AND ONCE OFF OF THE FREEWAY I TURNED THE CAR OFF AND THEN ON AND WAS LIKE NOTHING HAPPENED. AFTER I LOST ALL POWER THE SECOND INCIDENT, I TOOK IT INTO THE SHOP AND WAS TOLD THAT 2 CYLINDERS WERE COMPLETELY DESTROYED. HAD TO SPEND 2400 DOLLARS TO HAVE A NEW MOTOR PUT IN AND NOW THE THING IS HAVING PROBLEMS AGAIN. BATTERY LIGHT KEEPS COMING ON AND OFF WITHIN A SECOND AND THERE IS A LOUD TICKING NOISE WHILE IDLING. SOUNDS LIKE A...

I HAVE TWO MAJOR SAFTEY PROBLEMS THAT COULD HAVE ENDED IN A FATALITY.FIRST MY TRANSMISSION WENT OUT WITHOUT A WARNING WHILE I WAS ON THE INTERSTATE GOING 75 MPH AND A 18 WHEELER WAS BEHIND ME THE CAR DROPT DOWN TO 40 MPH AND I ALMOST GOT REARENDED BY THE SEMI.I HAD THE TRANSMISSION REBUILD.SECOND THING I PULLED OUT OF BURGERKING AND THE CAR HAS NO POWER AND ABOUT GOT TBONED AND THERES NO CHECK ENGINE LIGHT ON.

ORIGINALLY, THE TURBO WOULD LOSE BOOST AND THE ENGINE WOULD LOSE POWER. AFTER SOME TIME, PARTICULARLY DURING WET WEATHER, THE CAR WILL SUDDENLY VIBRATE, JOLT, AND THEN THE ENGINE WARNING CHIME SOUNDS. THE TACHOMETER DROPS TO ZERO, THE OIL PRESSURE LIGHT COMES ON, THE STABILITY CONTROL SHUTS OFF, THE GLOW PLUG LIGHTS FLASH, REAR WINDOW DEFROSTER WILL NOT WORK, CRUISE CONTROL WONT WORK, AND IF THE CAR IS SHUT OFF IT WILL NOT RESTART. THIS IS PARTICULARLY DANGEROUS DURING SNOW OR RAIN, AS THE CAR LOSES TRACTION CONTROL DURING WEATHER IN WHICH IT IS MOST IMPORTANT TO HAVE. ALSO, IF THE CAR DIES AND IS ON THE SHOULDER OF THE ROAD, DURING RAIN OR SNOW, THERE IS POOR VISIBILITY AND IT INCREASES THE RISK OF SOMEONE HITTING THE DISABLED CAR. I HAVE SEEN MANY MENTIONS OF THIS SAME EFFECT HAPPENING ON OTHER 2006 TDI MODELS, AND IT SEEMS TO BE...

CAMSHAFT FAILURE DUE TO EXCESSIVE WEAR ON A VEHICLE WITH 160,000 MILES DESPITE USING VW RECOMMENDED 505.01 SPECIFICATION OIL AND REGULAR MAINTENANCE. ENGINE DEVELOPED A RATTLING NOISE AT HIGHWAY SPEED, DECREASED PERFORMANCE, EXCESSIVE BLACK SMOKE COMING OUT OF TAIL PIPE, AND $1500 REPAIR BILL. DUAL MASS TRANSMISSION FLYWHEEL FAILURE ON A VEHICLE WITH 120,000 MILES RESULTED IN RATTLING NOISE IN THE TRANSMISSION, VIBRATION OF THE WHOLE VEHICLE AND $1200 REPAIR BILL. BOTH OF THESE ISSUES ARE WIDESPREAD. MULTIPLE OWNERS OF THIS YEAR/MAKE/MODEL HAVE EXPERIENCED THESE EXACT SAME ISSUES DUE TO POOR QUALITY PARTS ORIGINALLY INSTALLED BY THE MANUFACTURER. MANUFACTURER SHOULD RECALL THE AFFECTED VEHICLES AND FIX THESE ISSUES DUE TO THEM BEING WIDESPREAD. THERE ARE NUMEROUS DISCUSSIONS ON PUBLIC FORUMS OF THESE ISSUES AS WELL.

ABOUT 4 YEARS AGO ,I TOOK MY JETTA TO THE VOLKSWAGEN DEALER IN REGARD TO FRONT AIRBAGS RECALL. THE LIGHT WOULD NOT GO OFF. THEY REPAIRED IT, BUT AFTER A YEAR THE LIGHT CAME BACK ON AND STAYED ON. WHEN I CALL THE DEALER, I WAS TOLD I WOULD HAVE TO PAY FOR AN INSPECTION OF THE CAR BEFORE THEY CAN DETERMINE IF IT IS DEFECTIVE OR NOT. IT SEEMS TO ME THEY DID NOT FIX THE PROBLEM AND I SHOULD NOT HAVE TO PAY FOR IT. ALSO MY HORN WANT OFF, ONE DAY, AND THE ONLY WAY I WAS ABLE TO STOP IT , WAS TO PULL THE FUSE OUT. WHEN I PUT THE FUSE BACK , THE HORN WOULD NOT WORK. NOTHING WRONG WITH THE FUSE. . MY YELLOW ENGINE LIGHT KEEP COMING ON , ESPECIALLY WHEN I USE MY A/C AND THERE IS A VERY STRANGE SMELL...

I PURCHASED THIS 2006 VW JETTA TDI 1.9 TURBO DIESEL NEW IN 2006. AFTER ONLY 50K MILES, VW DEALERSHIP STATED THE TURBO CHARGER WENT BAD AND THE WARRANTY WAS INITIALLY REFUSED STATING IT WAS IMPROPER OIL USED. THIS WAS DISPROVED WITH RECEIPTS AND STILL CHARGED $500 OF A $2300 BILL. A FEW YEARS LATER NOW IN 2014,THE VEHICLE WAS TAKEN IN FOR NORMAL SERVICE AND THE NEXT WEEK, ENGINE LIGHT CAME ON. THE SAME THING HAPPENED AND VW STATES THE TURBO WENT BAD AND ARE GENERALLY ONLY GOOD FOR 50K MILES. AFTER SHARING MY ANGER ABOUT THIS, IT FELL UPON DEF EARS. I PURCHASED ANOTHER TURBO OUT OF CALIFORNIA, DUE TO NOT TRUSTING VW ANY LONGER. THIS NEW TURBO WAS INSTALLED AND DID NOT COME WITH THE WASTEGATE MODULE FOR IT WHICH IS REQUIRED FOR IT TO WORK. I SOON DISCOVERED THE WASTEGATE WAS BAD AND NEITHER OF THE TURBOCHARGERS...

WENT TO START CAR WAS MISFIRING CHECK ENGINE LIGHT CAME ON TOWED TO A SHOP THE TOLD ME MY TIMING CHAIN JUMPED AND IT WAS 2500 DOLLARS TO FIX. *TR

WAS GETTING HEAD ACHES WHEN DRIVING THE CAR AND SITTING IN TRAFFIC OR AT A STOP LIGHT. SMELLED A SULFUR LIKE SMELL FROM THE ENGINE COMPARTMENT. COULD HEAR LOUD BLOWING SOUNDS ON ACCELERATION. DEALERSHIP FOUND AN EXHAUST LEAK IN THE BACK OF THE DIESEL MOTOR FROM THE EGR COOLER ASSEMBLY. THE ENGINE WAS BLOWING SOOT IN TO THE ENGINE COMPARTMENT AND IT COULD BE HEARD AND SMELLED THROUGH THE FIREWALL. THIS IS A DIESEL SO THE EXHAUST CONTAINS CARCINOGENIC CHEMICALS. DIESEL EXHAUST CONTAINS A NUMBER OF POTENTIALLY TOXICOLOGICALLY RELEVANT ORGANIC COMPOUNDS ACCORDING TO THE EPA THAT HAVE HUMAN HEALTH HAZARDS ASSOCIATED WITH EXPOSURE. THE EGR COOLER IS NOT COVERED UNDER THE 8 YEAR 80K FEDERAL EXHAUST EMISSION WARRANTY EVEN THOUGH IT IS A MANDATED PART OF THE EXHAUST SYSTEM AS PART OF THE EXHAUST GAS RECIRCULATION SYSTEM. A SHAFT GOING THROUGH THE WALL OF THE EGR COOLER CONNECTING TO A...

THIS CAR HAD A DEFECTIVE CAMSHAFT AND LIFTERS. DEALER REFUSES TO REPAIR UNDER WARRANTY 2 YEARS AGO, NOW ITS GETTING WORST AND I DON'T HAVE THE MONEY TO REPAIR IT. *TR

DRIVING ALONG THE ROAD AND COOLANT SUDDENLY FLUSHED OUT OF CAR. WATER PUMP HAD TO BE REPLACED ALONG WITH TIMING BELT. OIL LEAKS IN MULTIPLE PLACES ARE STARTING TO APPEAR. I WONDERED WHY I WAS GOING THROUGH SO MUCH OIL. MECHANIC ALERTED ME TO THE POOR DESIGN AND BUILD AND TOLD ME TO CHECK OF OPEN RECALLS AND SIMILAR PROBLEMS. *TR

CURRENTLY EXPERIENCING A PROBLEM WITH THE BODY VALVE IN THE TRANSMISSION ON MY JETTA. THERE WAS AN EXTENDED WARRANTY FOR THIS PART THAT ENDED IN 2012. I AM EXPERIENCING THIS PROBLEM WITH MY CAR NOW AND IT IS A SAFETY HAZARD. MY CAR SHIFTS SO HARD BETWEEN 1ST AND 4TH GEAR AND WILL HAVE A SIGNIFICANT LAG TIME BETWEEN ACCELERATION WHICH DURING TRAFFIC, CAN CAUSE NUMEROUS PROBLEMS. VW WON'T OFFER ANY REIMBURSEMENT TO PAY FOR THIS TO BE FIXED BECAUSE IT IS OUTSIDE OF THE WARRANTY HOWEVER I THINK IT IS RIDICULOUS WHEN THEY KNOW THERE WAS AN ISSUE WITH THE PART IN THE FIRST PLACE. SO NOW I AM STUCK PAYING ANOTHER $1,500 REPAIR BILL FOR THIS CAR IN ADDITION TO ALL OTHER REPAIRS I HAVE PAID FOR. I KNOW I AM NOT THE ONLY ONE NOW EXPERIENCING THIS PROBLEM AFTER THE END DATE AS I HAVE CALLED NUMEROUS...

TL * THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 40 MPH, THE MOUNTS SNAPPED THAT SECURED THE ENGINE AND TRANSMISSION. AS A RESULT, THE ENGINE AND TRANSMISSION DETACHED FROM THE VEHICLE. THE VEHICLE STALLED AND WAS UNABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE TRANSMISSION AND FRONT DRIVER SIDE AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

I WAS DRIVING HOME FROM A SHORT TRIP(<5 MILES) WHEN MY CAR COMPLETELY STOPPED GOING ON A BUSY STREET. I WAS UNABLE TO MOVE THE CAR OUT OF THE WAY ON COMING TRAFFIC. I HEARD A LOUD POP PRIOR TO ITS LOSING POWER. I CALLED A TOW TRUCK WHO TRIED TO JUMP CAR BUT THE ENGINE WOULD NOT TURN OVER. I TOOK IT TO THE MECHANIC WHO HAD SOLD THE CAR TO ME AND I WAS TOLD THAT ONE OF THE PISTONS HAD RUPTURED THE ENGINE BLOCK. THEY HAD NO EXPLANATION ABOUT WHY THIS HAD HAPPENED. THE CAR HAD BEEN SERVICED( OIL CHANGE, VALVE REPAIR, TIMING BELT REPLACEMENT, WATER PUMP REPLACEMENT) ABOUT 500 MILES BEFORE. *TR

THE DIRECT SHIFT GEAR TRANSMISSION FAILED. THE CAR COULD NO LONGER GET OUT OF NEUTRAL. *TR

CAM SHAFT AND LIFTER INFERIOR QUALITY!!WHAT HAS HAPPENED ACCORDING TO OTHER OWNERS OF TDI'S THAT I HAVE TALKED TO IS THAT THE CAMSHAFT AND LIFTERS HAVE FAILED. THEY WERE BUILT INFERIOR AND BREAKDOWN. THIS CAUSES A LOT OF CONFUSION WITH MECHANICS TRYING FOR ENDLESS HOURS TO FIGURE OUT WHY ITS SMOKING. WITH A LOT OF RESEARCH I FOUND OUT THAT THE CAMSHAFT AND LIFTERS ARE INFERIOR AND BREAKDOWN. WHY DOES VOLKSWAGEN DO THAT TO PEOPLE, IT COST ME SO MANY THOUSANDS OF DOLLARS REPLACING TURBO, MASS AIR FLOW SENSOR TO REBUILDING THE ENGINE FOR GOD SAKE TO FIND THAT IT IS THE CAM AND THAT THIS IS A COMMON PROBLEM. VOLKSWAGEN SHOULD BE HELD ACCOUNTABLE FOR THIS. *TR

KNOCKING HEARD FROM ENGINE WHILE DRIVING ON HIGHWAY NEAR DESTINATION, APPROXIMATELY 300 MILES FROM HOME. VEHICLE ARRIVED AT DESTINATION, BUT WOULD NOT START. VEHICLE WAS TOWED TO MECHANIC. CAMSHAFT WEAR AND FOLLOWER BORE FOUND TO BE DAMAGED AND WAS REPLACED USING OEM PARTS. VEHICLE WAS USING FACTORY RECOMMENDED OIL AT REGULAR INTERVALS. CAM WEAR FOUND AGAIN ON 6/8/11, 195761 MILES. CAM SHAFT WEAR SEEN DURING TIMING BELT CHANGE. REPLACED CAM SHAFT, FOLLOWERS, AND BEARINGS. ONCE AGAIN, FACTORY RECOMMENDED OIL AND OIL CHANGE INTERVALS WERE USED. *TR

CAM WEAR FOUND ON 6/8/11, 195761 MILES. CAM SHAFT WEAR SEEN DURING TIMING BELT CHANGE. REPLACED CAM SHAFT, FOLLOWERS, AND BEARINGS. FACTORY RECOMMENDED OIL AND OIL CHANGE INTERVALS WERE USED. CAM SHAFT WAS ALSO REPLACED ON 11/03/09 AT 123086 MILES AFTER THE FOLLOWING INCIDENT: KNOCKING HEARD FROM ENGINE WHILE DRIVING ON HIGHWAY NEAR DESTINATION, APPROXIMATELY 300 MILES FROM HOME. VEHICLE ARRIVED AT DESTINATION, BUT WOULD NOT START. VEHICLE WAS TOWED TO MECHANIC. CAMSHAFT WEAR AND FOLLOWER BORE FOUND TO BE DAMAGED BEYOND REPAIR AND WAS REPLACED USING OEM PARTS. VEHICLE WAS USING FACTORY RECOMMENDED OIL AT REGULAR INTERVALS. *TR

AT APPROX 80-90K I STARTED HEARING A CLATTERING NOISE FROM THE ENGINE AND EXTRA NOISE WHEN IDLING. ALSO, THE CAR HAS A HARD TIME SHIFTING (AUTOMATIC TRANS). AFTER TAKING THE CAR TO A MECHANIC, I WAS TOLD THAT IT'S THE DSG DMF COMING APART AND RATTLING. AFTER DOING SOME RESEARCH, I FIND IT'S A COMMON PROBLEM. IT STARTED HAPPENING SHORTLY AFTER MY CAR WENT OUT OF CPO WARRANTY, WHICH EXPIRED AT 74K. I DIDN'T REALLY PAY THAT MUCH ATTENTION TO IT UNTIL IT GOT WORSE. THIS IS A 06 TDI MKV WITH AUTO DSG, BRM ENGINE. ALSO EXPERIENCING DIFFICULTIES WITH SOOT IN FUEL FILTER, LIKELY DUE TO FAULTY SEAL IN FUEL INJECTORS UNDER CAM SHAFT. ONCE AGAIN, COMMON PROBLEM ACCORDING TO MECHANICS AND ONLINE FORUMS ON THIS MODEL. THERE'S A RECALL ON THE DMF FOR THIS MODEL IN AUSTRALIA, NEEDS TO HAVE ONE FOR US. *TR

DURING A HEAVY RAIN, AND WHILE SLOWING TO APPROACH A STOP , MULTIPLE EMERGENCY WARNING LIGHTS APPEARED IN THE DASH DISPLAY. LOW OIL PRESSURE INDICATOR ADVISED TO SHUT OFF ENGINE IMMEDIATELY, GLOW PLUG INDICATOR FLASHED, AND TACHOMETER WENT TO ZERO (EVEN THOUGH ENGINE WAS STILL RUNNING). I SHUT OFF THE ENGINE, CHECKED OIL (LEVEL WAS FINE), BUT THE ENGINE WOULD NOT START. TOWED BACK HOME, AND 30 MINUTES LATER, ENGINE STARTED. NO CHECK ENGINE LIGHT AT ANY TIME. PROBLEM RECURRED AGAIN IN HEAVY RAIN SEVERAL WEEKS LATER. EXAMINED WIRING HARNESS AND FOUND TWENTY INDIVIDUAL WEAR POINTS IN THE WIRES WHERE THE INSULATION WAS WORN ENOUGH TO EXPOSE THE COPPER STRANDS. THERE WERE NUMEROUS OTHER WEAR POINTS WITH NO COPPER VISIBLE, BUT ALL OF THE INSULATION WEAR MATCHED THE CORRUGATION OF THE RIBBING IN THE PLASTIC WIRE LOOM COVERING. CLOSER INSPECTION OF THE WEAR POINTS REVEALED THE MOST PREVALENT AND SERIOUS...

VW IS VERY MUCH AWARE OF THE DEFECT REGARDING CAMSHAFT FAILURE IN THE ENGINE, RESULTING IN HIGH REPAIR COSTS AND DANGEROUS LOSS OF POWER THAT COULD RESULT IN A COLLISION. VW SOUTHTOWNE IN UTAH CALLED THE ENGINE "EXPERIMENTAL" BASICALLY ADMITTED THAT VW KNEW THERE WAS A PROBLEM AND ONLY BUILT THE ENGINE FOR 1.5 YEARS AS A RESULT. THEY ONLY RESPOND THAT THE CAR IS OUT OF WARRANTY AND IS THE CONSUMERS PROBLEM TO PAY FOR A $4000 REPAIR ONTO OF PAYING FOR THE LOAN ON THE CAR. *TR

A RATTLING SOUND BEGAN TO COME FROM THE ENGINE COMPARTMENT SHORTLY AFTER PASSING 85,000 MILES ON THE VEHICLE. SCANNED THE COMPUTER AND FOUND SEVERAL CODES FOR MISFIRES AND VACUUM LEAKS ON THE VEHICLE ECU. TOOK IT TO A SHOP AFTER PERFORMING ROUTINE MAINTENANCE DID NOTHING TO SMOOTH OUT ENGINE OPERATION. SHOP SHORTLY CONTACTED ME BACK WITH A QUOTE OF THE TIMING CHAINS WERE COMING APART AND THE ENGINE WAS SEVERELY OUT OF TIME. AFTER SOME RESEARCH ONLINE THIS APPEARS TO BE AN ISSUE WITH THE EARLY 2.5L MK5 JETTA ENGINE. *TR

THE VEHICLE STALLS WHENEVER DRIVING IN WET CONDITIONS ON THE HWY WHILE SNOWING OR RAINING. I HAVE LOST CONTROL OF THE VEHICLE AND HAVE BROKEN DOWN ON THE SIDE OF THE ROAD WITH NO SHOULDER AND FACING AN UPHILL INCLINE. ON EACH OCCASION I HAVE HAD MY CHILDREN IN THE VEHICLE WITH ME AND FACING HEAVY TRAFFIC IN BOTH DIRECTIONS. I WAS FORTUNATE TO HAVE A HIGHWAY PATROL OFFICER ASSIST ME IN PUSHING THE CAR TO OFF THE HIGHWAY THE LAST 3 TIMES. EACH TIME, THEY INFORMED ME THAT I SHOULD CONTACT VOLKSWAGEN AND LET THEM KNOW BECAUSE IT SHOULD DEFINITELY BE A FACTORY RECALL BASED ON THE DANGEROUS CIRCUMSTANCES. THE PROBLEM HAS BEEN IDENTIFIED ON TDI FORUMS HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=239987&PAGE=6 AS A WIRE CHAFING CONDITION CAUSED BY THE VIBRATION OF THE DIESEL ENGINE. I TOOK MY VEHICLE TO THE REPAIR SHOP 3 DIFFERENT TIMES AND THEY WERE UNABLE TO IDENTIFY THE...

ENTIRE CAMSHAFT HAS TO BE REPLACED, CAR IS INOPERABLE. THIS IS APPARENTLY A KNOWN ISSUE BUT VW OF AMERICA WILL NOT ACKNOWLEDGE THIS OR HELP WITH THE REPLACEMENT COST, WHICH IS SUBSTANTIAL. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT THERE WAS A RATTLING NOISE IN THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THE PIPING HAD BECOME LOOSE. THE VEHICLE WAS REPAIRED BY APPLYING A RUBBER GUARD HOWEVER, THE FAILURE RECURRED IMMEDIATELY AFTER THE REPAIRS. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY ADVISED HIM THAT THE DUEL MASS FLYWHEEL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 36. THE CURRENT MILEAGE WAS APPROXIMATELY 160,000.

MY WIFE AND I WERE DRIVING HOME AND SUDDENLY MY CAR STARTED JERKING AND MADE A "KNOCKING" SOUND, WITHOUT ANY WARNING (I.E. CHECK ENGINE LIGHT). WE WERE CLOSE TO HOME AND DECIDED TO CONTINUE ON; HOWEVER, IN THE NEXT COUPLE OF MILES, THE PROBLEMS PERSISTED, STILL WITH NO CHECK ENGINE LIGHT OR ANY INDICATION OF WHAT WAS WRONG WITH THE VEHICLE. OVER THE NEXT SEVERAL DAYS, WHILE PARKED ON A SECURED PREMISE, I STARTED THE CAR UP AND IT HAD AN ERRATIC LOPING SOUND. I PROCEEDED TO CALL A NEARBY VOLKSWAGEN DEALER AND SPOKE TO TWO CERTIFIED VW MECHANICS, WHO FAILED TO ACKNOWLEDGE THE ISSUE THAT THERE WAS NO WARNING INDICATION BEFORE THE CAR STARTED TO ACT UP AND SAID TO BRING IT IN TO SWAP OUT THE ENGINE AT APPROX. $7500; THEY DISMISSED THE PROBLEM AS "NORMAL WEAR AND TEAR". I RESEARCHED THE PROBLEM ON THE INTERNET AND IT...

VEHICLE LOST POWER. ENGINE BECAME LOUDER. CAR SHUDDERS UNDER ACCELERATION. CAMSHAFT FAILURE. CAMSHAFT MUST BE REPLACED. KNOWN ISSUE WITH THIS CAR. *TR

AT 130,623 MILES OUR JETTA HAD TO HAVE THE CAMSHAFT AND LIFTERS REPLACED. THE LOBES ON THE CAMSHAFT HAD COMPLETELY WORN OFF AND THE LIFTERS HAD PITTED. I FEEL LIKE OUR DIESEL MOTOR HAS AGED PREMATURELY AND THERE IS AN UNDERLYING PROBLEM THAT VW IS IGNORING. THIS IS A COMMON PROBLEM FOR THIS MODEL AND YEAR. WE ARE HAVING BOTH REPLACED, BUT UNTIL THE ROOT OF THE PROBLEM IS FOUND THERE WILL BE AN ISSUE AGAIN. VW MUST KNOW OF THIS PROBLEM. THEY STOPPED PRODUCTION OF THE TDI JETTA IN 2006. THE 2006 WAS THE LAST YEAR BEFORE STOPPING PRODUCTION. WHY WOULD THEY STOP MAKING A CAR THAT WAS IN SUCH HIGH DEMAND WITH THE RISING COST OF DIESEL AND GAS. THEY KNEW OF AN ISSUE IN THE CAR THAT THEY COULDN'T FIGURE OUT. NOW THEY IGNORE THE PROBLEM AND CONTINUE TO BLAME THE CUSTOMER FOR POOR MAINTENANCE. THE CAR...

ENGINE LOSS OF POWER, BLACK SMOKE FROM EXHAUST AND PINGING NOISE FROM ENGINE VEHICLE STALLED A FEW TIME IN TRAFFIC ALMOST CAUSING AN ACCIDENT WITH OTHER VEHICLES DRIVING VEHICLE TO WORK, STARTED MAKING NOISE AND DECIDED TO DRIVE TO VW DEALERSHIP. DEARLERSHIP FIRST DIAGNOSED THE PROBLEM AS A BAD CLUTCH. UNDER MY RECOMMENDATION CAMSHAFT WAS INSPECTED AND FOUND TO BE DEFECTIVE AS WELL AS THE LIFTERS THAT CONTACT THE CAMSHAFT. DEALER SAYS THIS IS NOT A VW PROBLEM AND WAS SURPRISED TO SEE A PROBLEM WITH THE CAMSHAFT. IF YOU LOOK ON THE INTERNET, MANY TDI VW OWNERS ARE EXPERIENCING THE SAME PROBLEM. THIS PROBLEM IS NOT BEING RECONGIZED BY VW AND IS COSTING OWNERS A LOT OF MONEY IN REPAIRS AS WELL AS CREATING UNSAFE DRIVING CONDITIONS FOR OWNERS OF THIS VEHICLE. *JS

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT A LOUD NOISE EMITTED FROM THE DRIVE TRAIN WHENEVER THE VEHICLE WAS OPERATED. THE NOISE SOUNDED LIKE SOMETHING WAS BANGING UNDER THE HOOD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT EXAMINED THE VEHICLE AND STATED THAT THE FLY WHEEL WITHIN THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 78,000.

CAMSHAFT BEGAN KNOCKING AROUND 100,000 MILES. MANY OTHER '06 JETTA TDI HAVE HAD PREMATURE CAMSHAFT FAILURES AS WELL. KNOCKING INTENSIFIED JUST BEFORE 101,000 MILES. TOOK IT TO MECHANIC WHO WAS VERY FAMILIAR WITH THE ISSUE, AS HE HAS SEEN MORE THAN HIS SHARE. HE SAID THE EARLIEST FAILURE HE HAS SEEN WAS AT AROUND 40,000 MILES. I HAD TO GO TO GREAT EXPENSE TO REPLACE CAM FOLLOWER, CAMSHAFT AND CAM BEARINGS. IT ALSO CAUSED PREMATURE WEAR ON MY LIFTERS, WHICH I EXPECT I'LL HAVE TO DO SOON, AS THEY ARE STARTING TO "TICK". I LOVE MY TDI, AND HAVE MADE SURE ALL SERVICE WAS DONE PROMPTLY. I AM FRUSTRATED THAT VWAG HAS DENIED THERE IS A PROBLEM. IF ENOUGH PEOPLE COMPLAIN, THEN THEY WILL HAVE TO ADMIT THAT POOR ENGINEERING IS THE CAUSE OF THE PREMATURE CAMSHAFT FAILURES THAT ARE PLAGUING PUMPED USE OWNERS. *TR

ON HIGHWAY GOING APPROX 60 MPH, CAR LOCKED UP, SKIDDING FOR ABOUT 50 FEET. WAS UNABLE TO ENGAGE CLUTCH, ENGINE WAS STILL RUNNING THOUGH. GOT CAR TOWED TO DEALERSHIP, DISCOVERED ENGINE MOUNT BOLT HAD SHEARED OFF, CAR HAS NEVER BEEN IN AN ACCIDENT AND HAS HAD ALL OIL CHANGES/ETC ( 2K MILES LATE FOR 60K SERVICE). *TR

ENGINE STALLED WHILE DRIVING AT LOW SPEED APPROACHING A STOP LIGHT AND COULD NOT RESTART THE ENGINE. THE ENGINE CRANKED BUT WOULD NOT START. THIS HAS HAPPENED SEVERAL TIMES AND RE-OCCURRED EVEN AFTER THE DEALER REPLACED THE FUEL PUMP AND FILTER. AFTER ONLY 40 MILES AND ONE DAY OF DRIVING IT IS AT THE DEALER FOR REPAIR. *JS